E F Johnson 2424310 Non-Broadcast Transceiver User Manual 4300ServMan VHF

E. F. Johnson Company Non-Broadcast Transceiver 4300ServMan VHF

manual part 2

51 As forward biasing current increases, the impedance decreases to a low level. Therefore, the RF level of the signal applied to Q6 increases as the bias current from the power control circuit increases. 5.2.2.2 PA RF DEVICE (Q6) Impedance matching for Q6 is provided by several capacitors, inductors, and sections of microstrip. Q6 is an N-channel enhancement mode lateral MOSFET. The bias voltage (which is required for the device to turn on) is controlled by the transmit signal. It is applied to the gate and controlled by the logic through shift register U1. Therefore, this device is turned off in the receive mode which improves isolation. Several capacitors, inductors, and resistors isolate this supply from RF. Likewise, the 13-volt RAW BAT supply applied to the drain is isolated by similar components. From the output of the variable attenuator, the signal is fed to Q6. Q6 operates as a single-ended device. It produces an output power of up to 35 watts. 5.2.2.3 FORWARD POWER DETECTOR, ANTENNA SWITCH, LOW-PASS FILTER The power control circuit senses Q6 output power to control the power output. A directional coupler senses the forward power signal. This signal is then rectified by CR8 and applied to the power control circuit. This signal is a DC voltage that increases in proportion to the level of forward power. Refer to Section 5.2.2.4 for more information on power control. PIN diodes CR9, CR11, CR12, and CR15 form an antenna switch that switches the antenna to the transmitter in the transmit mode and the receiver in the receive mode. As stated in Section 5.2.2.1, PIN diodes have very high impedance when in the off mode and very low impedance when forward biased. Transistors Q7 and Q9 are on in the transmit mode and off in the receive mode. In the transmit mode all four diodes are forward biased. The transmit signal then has a low impedance path through CR9 to the low-pass filter and is blocked from the receiver by a grounded quarter-wave line formed by C64, L15, and C66. A grounded quarter-wave lines presents very high impedance at the non-grounded end. PIN diodes CR11 and CR15 and a second quarter-wave line formed by C76, C77, and L17 provide additional isolation. In the receive mode, all four diodes are in the off mode. Therefore, the receive signal from the antenna is blocked from the power amplifier by CR9 and has a low impedance path through L15, C74, L17, and C67 to the receiver in the RF module. From the antenna switch the RF signal is applied to a low-pass filter formed by L11-L13 and several capacitors and sections of microstrip. This filter attenuates harmonic frequencies above the transmit band that could cause adjacent channel interference. R53 dissipates static buildup in the antenna. 5.2.2.4 POWER CONTROL Introduction
52 The power control circuit maintains a constant power output as changes occur in power amplifier temperature and voltage. It does this by sensing forward power and then varying the drive to Q6 to maintain a constant output power. The drive to Q6 is controlled by varying the voltage applied to the variable attenuator circuit described in Section 5.2.2.1. In addition, the current applied to final amplifier Q6 is sensed, and if it becomes excessive, power is cut back to a low level. The power output level is set in 127 steps by a Digital-to-Analog (D/A) converter formed by shift register U1 and several resistors. This converter is controlled by the microcontroller to provide the following functions: • It allows the RF power output level to be adjusted using the PCTune™ software. • It allows the microcontroller to cut back power if the power amplifier temperature sensed by thermistor TR1 becomes excessive. • It allows high and low power levels to be selected by the user or to be fixed by programming using the PCConfigure™ software. Forward Power Sense The forward power signal from the directional coupler is applied to pin 2 of amplifier U2-A. This is a DC signal that increases proportionally to forward power. The other input to U2-A on pin 3 is a DC reference voltage from the D/A converter. This signal sets the power output of the transmitter. U2-A is a difference amplifier which amplifies the difference between the reference voltage on pin 3 and the forward power signal on pin 2. The turn-on time of U2-A is controlled by the time constant of C17 and R28, and negative AC feedback to prevent oscillation is also provided by C17. This circuit operates as follows: Assume the output power attempts to increase. The DC voltage applied to U2-A, pin 2 then increases which causes the output voltage on pin 1 to decrease. Transistors Q1 and Q2 then turn off slightly which decreases the supply voltage to the variable attenuator circuit. The input power to Q6 then decreases. The Q10 output power then decreases to maintain a constant power output. R26 and R24 limit the voltage gain of Q2 and Q1 to approximately two volts. Delayed PTT Transistor Q3 is used to delay power output for a short time after the transmitter is keyed. This allows the synthesizer and exciter to stabilize so that the transmitter does not transmit off frequency. The signal which controls Q3 is from microcontroller on the logic board. In the receive mode this output is low, so Q3 is off. Pin 2 of U2-A is then pulled high by the 8-volt supply applied through R29 and CR1. This causes the output on pin 1 of U2-A to go low which shuts off Q2 and Q1. Then when the transmitter is keyed, after a short delay Q3 then turns on and diode CR1 is reverse-biased. Only the forward power signal is then applied to pin 2 of U2-A. Over-Current Shutdown Current to Q6 is monitored by sensing the voltage drop across R33. Pins 3 and 6 of U3 are connected across this resistor. As current increases, the output voltage on U3 pin 8 increases. This voltage is applied to Schmitt trigger U2-B. When the voltage on pin 6 rises above the reference on pin 5, the output on pin 7 goes low. This lowers the voltage applied to U2-A, pin 3 which
53 lowers the power control voltage to the variable attenuator. This results in lowering the power output to approximately 25% of full power.
54 SECTION 6 ALIGNMENT PROCEDURE 6.1 GENERAL 6.1.1 INTRODUCTION The following alignment procedure should be performed if repairs are made that could affect the factory alignment or if adjustments may have changed for some other reason. To verify radio operation, the performance tests in Sections 6.5 and 6.6 can be run. To perform transceiver alignment, the following are required: • PC-compatible computer • Remote Programming Interface (RPI), Part No. 023-5300-000. • PCTune software, Part No. 023-9998-499. All adjustments are set digitally using the computer. Therefore, there is no need to disassemble the transceiver to access adjustment points. In addition, audio test signals are generated internally, so an audio generator is not required. The required test equipment is shown in Figure 6-1. 6.1.2 TUNE SOFTWARE General The PCTune software is a Windows® program. Minimum software and hardware requirements are as follows:
55 • Windows® 95/98/NT/2000 (3.1 cannot be used) • Pentium® processor or equivalent • 16 MB of RAM • A hard disk drive with at least 3 MB of free space • A CD-ROM drive • An available serial port Software Installation Proceed as follows to install this software: 1. Close all applications that are currently running (other than Windows). 2. Insert the CD-ROM containing the PCTune software into the drive. 3. From the Windows taskbar, choose RUN and open SETUP.EXE on the drive being used. Alternatively, use File Explorer and double click SETUP.EXE. 4. Follow the instructions on the screen. The program is automatically loaded on the hard drive and startup shortcuts or groups are created. Starting PCTune Select Start in the taskbar, then Programs > PCTune > PCTune. Exiting PCTune Select File > Exit or click the button. Online Help Online help is not available. 6.1.3 PCTUNE VERSION REQUIRED PCTune, Version 2.0.0 or later is required to tune the RF board. The version number can be displayed by selecting the Help > About menu. 6.2 MAIN SCREEN The main PCTune screen is shown in Figure 6-2. Information on the various parts of this screen follows:
56 Menu Bar - Used to select the menus described in Sections 6.3.1-6.3.5. Tool Bar - These buttons are used to quickly select functions as follows: - Displays the screen used to set serial port parameters (see Section 6.3.3). - Selects the Partial Tune mode the same as the Transfer > Tune Partial menu (see Section 6.3.3) This mode allows manual selection of the desired Tune Category and then automatically steps through the various settings for that adjustment. - Selects the Edit Mode which allows parameters in the selected screen to be changed without stepping through each adjustment. - Reads and displays the current parameters programmed in the radio the same as the Radio > Read Tune Parameters menu (see Section 6.3.3). - Writes the current tune parameters to the radio the same as the Transfer > Write Tune Parameters menu (see Section 6.3.3). This occurs automatically when a Partial Tune adjustment is completed. - Exits the current Tune Category without writing parameters to the radio. Radio Information When tuning parameters are read from a radio by clicking the button or selecting the Transfer > Read Parameters menu, the following information is displayed in the top part of the screen: Type - The Radio Series selected by the Radio menu (see Section 6.3.2). The correct series must
57 be selected for communication with the radio to occur. Band - The radio frequency band of the radio displayed after information is read from radio. Do not select the band using Tools > Set Band (Section 6.3.4) because this may make the radio nonfunctional. Software DSP - The first number is the version number of the radio firmware (Flash/operating code), and the second number is the version number of the DSP software. ESN - The Electronic Serial Number electronically stored in the radio. Tuning Categories These buttons select the tuning adjustment to be performed. Different functions are displayed for the 51xx and 53xx. If the Partial tune mode is selected, these buttons select the particular adjustment that is performed. Mode/Tool Tip Information on the bottom line of the screen indicates the current tune mode and information on the selected button on other information. 6.3 MENU BAR DESCRIPTION 6.3.1 FILE MENU Selecting File > Exit closes the PCTune program. 6.3.2 RADIO MENU [Insert 4300 radio menu] The Radio menu shown above selects the radio type. [Insert correct selections for 4300] The correct radio type must be selected for communication with the radio to occur. 6.3.3 TRANSFER MENU COM Ports - Displays the following screen which selects the serial port (1-12) and baud rate
58 (9600/ 19200) used for communication with the radio. Select the computer port to which the test cable is connected (see Section 6.4.1), and 19200 baud is normally selected. These parameters default to the last selected condition the next time the program is started. Read Tune Parameters - Selecting this function or clicking the button reads the tune parameters currently programmed in the transceiver and displays them in the various screens. NOTE: Values in the various screens are for reference only and adjustments should be done only by using the Partial Tune function. Write Tune Parameters - Selecting this function or clicking the button writes the current tune parameters to the radio. This occurs automatically when a Partial Tune adjustment is completed. Tune Complete – Not available. This function automatically steps through all the tests required to tune the radio. Tune Partial - Selecting this function or clicking the button selects the Partial Tune mode. This mode automatically steps through all the adjustments of the currently selected Tune Category. 6.3.4 TOOLS MENU Reset Radio - Resets the radio control logic similar to cycling power. This can be used, for example, to change the radio series or band or exit an adjustment before it is complete. Set Band - Selects the operating band of the radio. All tuning values are reset to the factory defaults.
59 CAUTION: Do not select this function because it can make the radio non-functional. Reset Passwords - Erases all password information contained in the radio. This function can be used, for example, to allow reprogramming of passwords if they are lost. NOTE: Radio personality information is not erased by this function. Erase EEPROM CAUTION: This function erases important radio programming information as described below. Complete -Erases all EEPROM information, including factory programmed parameters. CAUTION: Do not select this function because the radio must be returned to the factory to make it operational again. Parms Only - Erases all personality information. NOTE: The radio must be reprogrammed after this function is selected. Tx/Rx Tests - Selects a screen which is used to check digital (Project 25) receive and transmit performance. Refer to Section 6.5 for more information. Restore Rx Front End Parameters - Programs the radio with default receive front end tune parameters. Other parameters remain unchanged. 6.3.5 HELP MENU Displays the version number of the PCTune software and other information. 6.4 TUNING PROCEDURE 6.4.1 CONNECTING TEST SETUP 1. With transceiver power turned off, connect the RPI to an unused serial port of the computer using a suitable cable (see Section 4.1.3). 2. Connect the RPI to the microphone jack of the transceiver using programming cable, Part No. 023-5300-005 (see Figure 6-1). 3. If the receiver squelch adjustment will be made, connect a SINAD meter to the Speaker Audio Out jack on the RPI (see Figure 6-3). This is a low level fixed audio output, and a 2.6 mm (3/32”) phone jack is used.
60 Figure 6-3 RPI Front Panel 4. Connect a wattmeter and a suitable load to the antenna jack of the transceiver for the transmitter tests. For the receiver tests, connect the signal generator to the antenna jack through a 6 dB or greater isolation pad. 6.4.2 STARTING AND CONFIGURING PCTUNE 1. Start the program as described in Section 6.1.2 and turn transceiver power on. Select Transfer > COM Port and make sure that the correct serial port and the 19200 baud rate are selected (see Section 6.3.3). 2. Select the Radio menu and make sure the correct radio series (43xx) is selected [What is the correct menu selection?] (see Section 6.3.2). 3. Select Transfer > Partial Tune and click the button for the desired Test Category. 4. Follow the instructions displayed on the screen to complete the various adjustments required for a particular setting. Then repeat for other applicable Test Categories. 6.5 DIGITAL PERFORMANCE TESTS 6.5.1 GENERAL This section describes how to check the performance of the radio on digital Project 25 channels. The PCTune software includes a Tools > Tx/Rx Tests menu that displays the screen used for these tests. • To perform these tests, a Digital Communication Analyzer such as Motorola R2670 or IFR 2975 is required. • These tests follow the TIA-102-CAAA-A “Digital C4FM/CQPSK Transceiver Measurement Methods” specification. Refer to that document for more information. • A P25 conventional channel preprogrammed by the PCConfigure software is used for testing. The PCTune software does not select a specific test channel. The test channel must be programmed with the following options:
61 NAC - 293 (hex) TGID (Talk Group ID) -1 Frequency - Any frequency in radio operating band 6.5.2 RECEIVE TEST SETUP 1. Connect the test setup and start and configure the PCTune software as described in Section 6.4. Select the Tools > Tx/Rx Tests menu to display the Tx/Rx Tests screen. Then in the Test Type drop-down list select Receive to display the following screen. 2. Connect the Digital Communication Monitor to the antenna jack using a 6 dB or greater isolation pad. Set the Monitor output for the “1011” test pattern. 6.5.3 RECEIVE SENSITIVITY TEST 1. A tone should be heard from the radio speaker if the analyzer is set properly. Select the “Short” or “Long” test in the Test drop down list and the radio should mute. 2. Set the analyzer output level for 0.35 µV (–116 dBm) at the receiver antenna jack. The Bit Error Rate (BER) should be 5% or less. (This is a ratio of the receive bit errors to the total number of bits transmitted.) 3. Increase the analyzer output level to 1000 µV (–47 dBm). The BER rate should be less than 0.01%. This is the BER Rate Floor. 6.5.4 TRANSMITTER TESTS 1. If applicable select the Tools > Tx/Rx Tests menu to display the Tx/Rx Tests screen. Then in the Test Type drop-down list select Transmit to display the following screen. Connect a dummy load to the radio antenna jack. Monitor the transmit signal with the Digital Communication Monitor.
62 2. Select the Low Deviation test and set the analyzer as required to measure transmitter deviation. This test generates continuous repetitions of bits 10100000. Deviation should be 848-1037 Hz. 3. Click the “PTT” button to transmit the tone. When finished, click that button again to turn the transmitter off. 4. Select the “High Deviation” test which transmits a standard transmitter test pattern. Deviation should be 2544-3111 Hz. 5. The “1011 Hz” test transmits a standard 1011 Hz tone similar to that used for the receiver test. This tone can be used to check the operation of other radios. 6. The “Silence” test transmits a standard silence test pattern which produces no receive audio output by the receiving radio. This tone can also be used to test other radios. 7. Select “Normal” to transmit a standard voice signal by speaking into the radio microphone. 6.6 ANALOG PERFORMANCE TESTS 6.6.1 GENERAL The PCTune software is not used for analog channel performance testing. Simply program the desired channels using the PCConfigure software as described in Section 4. The RPI is still required to monitor the audio output signal from the radio. Depending on the application, 12.5 kHz and 25 kHz test channels may need to be programmed. Also, test channels programmed with or without Call Guard® (CTCSS/DCS) squelch control may be required. 6.6.2 RECEIVER PERFORMANCE TESTS 1. Connect a signal generator to the antenna jack using a 6 dB or greater pad. Set the output for the channel frequency, modulated with 1 kHz at the following deviation: 12.5 kHz Channels - 1.5 kHz 25 kHz Channels - 3.0 kHz 2. Connect a SINAD meter to the receive audio jack of the RPI (see Figure 6-3) This is a low level fixed audio output. SINAD Sensitivity
63 3. Set the signal generator output level for 1000 µV (–47 dBm) at the antenna jack. 4. Decrease the signal generator output to obtain 12 dB SINAD. The signal generator output should be 0.35 µV (–116 dBm) or less for 25 kHz channels, or 0.50 µV (–113 dBm) or less for 12.5 kHz channels. Audio Power Output and Distortion 5. Connect a distortion meter across the speaker load. Return the generator output to 1000 µV. Distortion should be 3% or less. Squelch Sensitivity 6. Increase the signal generator output from zero and note the SINAD when unsquelching occurs. It should be approximately 8 dB. 6.6.3 TRANSMITTER PERFORMANCE TESTS 1. Connect a wattmeter and dummy load to the antenna jack. Monitor the transmit signal with a communication monitor. Transmit Frequency 2. Monitor the transmit frequency and at room temperature it should ±100 Hz. At other temperatures [–22° to +140° F (–30° to +60° C)], it must be within 2.5 PPM. This also checks the receive frequency. Transmit Power 3. Transmit power should be in the following ranges. High and low levels can be preset anywhere in this range by PCTune. The factory default for high power is the maximum shown below, and low power is half that value. Standard Models -10-50 Watts Transmit Modulation 4. Monitor the transmit modulation with a modulation meter. Speak into the microphone with a normal voice. Modulation should be approximately as follows with no CTCSS/DCS signaling present: 12.5 kHz Channels - 1.4 kHz 25 kHz Channels - 3.4 kHz
64 5. Select a channel programmed with Call Guard (CTCSS/DCS) signaling. Maximum total Call Guard and voice modulation should be approximately as follows: 12.5 kHz Channels - 2.3 kHz 25 kHz Channels - 4.7 kHz
65 SECTION 7 PARTS LIST
66 SECTION 7 PARTS LIST Ref No. Description Part No. CHASSIS, HARDWARE, AND MISCELLANEOUS A 200 Interface board assembly (see separate listing which follows) 023-5500-200A 300 Receiver/exciter assembly (VHF) (see separate listing on pageTBD) 023-5517-212 Receiver/exciter assembly (UHF) (see separate listing on page TBD) 023-5567-212A 301 Accessory pigtail cable (internal) 597-2002-230A 302 Remote/acc pigtail cable (internal) 597-2002-249A 303 Remote pigtail cable (internalfor second control unit) 597-2002-251A 400 Logic board assembly (see separate listing on page TBD) 023-5500-600A 500 VHF 50W PA bd assy 50W mod. (see separate listing on page 7-Error! Reference source not found.) 023-5315-531 UHF 40W PA bd assembly (see separate listing on page 7-Error! Reference source not found.) 023-5365-501A 810 Front panel assembly (frt mt) (see separate listing on page 7-) 023-5300-810 CH 101 Chassis, std VHF models 015-0970-001 Chassis, std UHF models 015-0970-002EP 001 No. 6 terminal lug 586-0005-106EP 002 Ferrite bead, .375 x .375 517-2002-003EP 003 Ferrite block (for J200) 517-2002-020EP 920 Snubber, bot shield for 018-1134-136encryp mod HW 001 Captive screw, cover 537-9007-045HW 002 Screw, 6-32 x 5/16 Torx 575-0006-010HW 003 Plug, option (in unused chass hole) 032-0792-075HW 004 Audio amp U1 clip 017-9700-001HW 005 O-ring, 1/8 x 1/4 cover screw 574-2002-001HW 006 Nylon washer, cover screw 596-4408-015HW 007 Split rubber grommet 1/8ID 574-0002-015HW 009 Flat washer, cover screw 596-9408-009HW 010 Screw, 4-40 x 5/16 phil pan hd 575-0604-010HW 011 Washer, No 4 split lock 596-1304-008HW 012 Washer, No. 4 split lock 596-1304-008HW 020 1/4 x 1.20 x 1.90 urethane pad 018-1007-250HW 150 Screw, 4-40 x 5/16 phil pan hd 575-0604-010HW 151 Screw, 6-32 x 3/8 phil flat hd 575-8206-012HW 152 Screw, 8-32 x 3/8 hex socket hd 575-9076-012HW 202 Screw, 4-40 x 1-1/8 mach pan hd 575-1604-036 J 002 RF – PA board connector 515-9006-110J 200 Connector, 28-pin inline header 515-7181-038 MP 002 Cover, top black 015-0970-007MP 003 Cover, bottom black 015-0970-009
67 MP 004 Gasket, blank front panel (remote) 032-0792-068MP 005 Front panel, blank (remote) 032-0792-005MP 156 Gasket, top cover 018-1136-136MP 157 Gasket, bottom cover 018-1136-134MP 300 Foam tape, dbl side 574-3002-013MP 505 Grounding clip (rx/ex assy) 017-9700-003MP 601 Shield, low-pass filter wrap around 017-9700-010MP 602 Cover, low-pass filter cover 017-9700-011 NP 001 Label, RS 5300 559-5300-100NP 002 Label, EFJohnson 559-9001-310 W 103 Cable assy, display - logic bd 023-5300-025W 110 Interface pigtail, motorcycle F DB25 597-2002-280W 501 Pwr pigtail cable assembly, std PA 597-2002-235W 502 RF pigtail cable assembly, std PA 597-2002-240 INTERFACE BOARD Part No. 023-5500-200 C 002 470 µF 25V electrolytic 510-4064-471C 003 100 µF 25V electrolytic 510-4425-101C 004 1.0 µF 10V tantalum smd 510-2624-109C 005 .1 µF ±5% X7R 50V cer smd 510-3609-104C 006 .1 µF ±5% X7R 50V cer smd 510-3609-104C 007 .1 µF ±5% X7R 50V cer smd 510-3609-104C 009 470 pF ±5% NPO cer smd 510-3602-471C 010 .1 µF ±10% X7R 50V cer smd 510-3606-104C 011 .1 µF ±10% X7R 50V cer smd 510-3606-104C 012 .1 µF ±10% X7R 50V cer smd 510-3606-104C 013 4.7 µF 10V tantalum smd 510-2624-479C 014 4.7 µF 10V tantalum smd 510-2624-479C 015 .01 µF ±5% X7R 50V cer smd 510-3609-103C 028 .1 µF ±5% X7R 50V cer smd 510-3609-104C 029 470 pF ±10% 25V cer smd 510-3681-471 CR 001 10V zener SOT-23 523-2016-100CR 002 Switching diode SOT-23 523-1504-002 J 201 Connector, 20-pin 515-7111-230J 202 Connector, 30-pin 515-7106-430 L 001 270 nH smd inductor 542-9017-274L 002 270 nH smd inductor 542-9017-274L 003 270 nH smd inductor 542-9017-274 P 100 Header, 2-pin friction lock 515-9031-201P 101 Header, 3-pin friction lock 515-9031-202P 102 Header, 3-pin friction lock 515-9031-202PC 001 PC board, interface revision 2 035-5500-200 2 Q 001 NPN general purpose 576-0003-658Q 002 NPN general purpose 576-0003-658Q 003 NPN general purpose 576-0003-658Q 004 NPN general purpose 576-0003-658 R 002 2.2 ohm ±5% 1W smd 569-0175-229R 003 10k ohm ±5% 1/8W smd 569-0105-103R 004 47k ohm ±5% 1/8W smd 569-0105-473R 005 10k ohm ±5% 1/8W smd 569-0105-103R 006 7.5k ohm ±5% 1/8W smd 569-0105-752R 008 1k ohm ±5% 1/8W smd 569-0115-102R 009 1k ohm ±5% 1/8W smd 569-0115-102R 010 1k ohm ±5% 1/8W smd 569-0115-102R 011 39k ohm ±5% 1/8W smd 569-0155-393R 012 12k ohm ±5% 1/8W smd 569-0155-123R 013 10k ohm ±5% 1/8W smd 569-0115-103R 014 10k ohm ±5% 1/8W smd 569-0115-103R 015 Zero ohm jumper 569-0115-001R 016 10k ohm ±5% 1/8W smd 569-0115-103R 017 3k ohm ±5% 1/8W smd 569-0115-302
68 R 018 10k ohm ±5% 1/8W smd 569-0115-103R 019 Zero ohm jumper 569-0115-001R 020 10k ohm ±5% 1/8W smd 569-0115-103R 021 10k ohm ±5% 1/8W smd 569-0115-103R 022 10k ohm ±5% 1/8W smd 569-0105-103R 023 12k ohm ±5% 1/8W smd 569-0115-123R 024 12k ohm ±5% 1/8W smd 569-0155-123R 025 20k ohm ±5% 1/8W smd 569-0155-203R 026 13k ohm ±5% 1/8W smd 569-0155-133R 027 10k ohm ±5% 1/8W smd 569-0115-103R 028 100k ohm ±5% 1/8W smd 569-0115-104R 029 100k ohm ±5% 1/8W smd 569-0115-104R 030 100k ohm ±5% 1/8W smd 569-0115-104R 031 10k ohm ±5% 1/8W smd 569-0115-103R 032 10k ohm ±5% 1/8W smd 569-0115-103R 033 10k ohm ±5% 1/8W smd 569-0115-103R 034 10k ohm ±5% 1/8W smd 569-0115-103R 035 10k ohm ±5% 1/8W smd 569-0115-103R 036 10k ohm ±5% 1/8W smd 569-0115-103R 037 39k ohm ±5% 1/8W smd 569-0155-393R 038 470 ohm ±5% 1/8W smd 569-0155-471R 039 10k ohm ±5% 1/8W smd 569-0155-103R 040 470 ohm ±5% 1/8W smd 569-0155-471R 041 10k ohm ±5% 1/8W smd 569-0155-103 U 001 Audio amp, 22W TDA1519 544-2004-003U 002 Voltage regulator, adj REG103UA 544-2603-057U 003 Op amp, dual LM2904 544-2019-004U 004 Dig potentiometer, 2-ch AD8402 544-0004-213U 006 Voltage regulator, adj REG103UA 544-2603-057U 007 Multiplexer, triple 4053 544-1014-053U 008 Voltage regulator, adj REG103UA 544-2603-057U 009 CPLD prog logic device XC2C64 544-5001-420U 010 Op amp, dual LM2904 544-2019-004 VHF RECEIVER/EXCITER ASSEMBLY Part No. 023-5517-212 A 001 Interconnect board assembly (see separate listing which follows) 023-5500-050A 100 RF board assembly, VHF 585-5500-100 HW 001 Screw, 2-56 x 3/16 pan hd 575-1602-006HW 002 Screw, 4-40 x 1/4 pan hd 575-1604-008HW 003 Lockwasher, internal 596-2102-006HW 004 Washer, split lock #4 ZPS 596-1304-008 MP 002 Metal RF board housing 015-0970-014MP 003 Cover for housing MP2 015-0970-015MP 004 Grounding clip 537-5001-005W 001 Coax assy, right angle 597-3008-001 INTERCONNECT BOARD ASSEMBLY Part No. 023-5500-050 C 001 39 pF ±5% NPO 50V cer smd 510-3674-390C 002 39 pF ±5% NPO 50V cer smd 510-3674-390C 005 39 pF ±5% NPO 50V cer smd 510-3674-390C 007 39 pF ±5% NPO 50V cer smd 510-3674-390C 008 39 pF ±5% NPO 50V cer smd 510-3674-390C 009 39 pF ±5% NPO 50V cer smd 510-3674-390C 011 39 pF ±5% NPO 50V cer smd 510-3674-390C 012 39 pF ±5% NPO 50V cer smd 510-3674-390C 014 39 pF ±5% NPO 50V cer 510-3674-390
69 smd C 016 39 pF ±5% NPO 50V cer smd 510-3674-390C 017 .1 µF X7R ±10% 50V cer smd 510-3675-104C 018 39 pF ±5% NPO 50V cer smd 510-3674-390C 019 39 pF ±5% NPO 50V cer smd 510-3674-390C 020 39 pF ±5% NPO 50V cer smd 510-3674-390C 021 39 pF ±5% NPO 50V cer smd 510-3674-390C 022 39 pF ±5% NPO 50V cer smd 510-3674-390C 024 39 pF ±5% NPO 50V cer smd 510-3674-390C 025 39 pF ±5% NPO 50V cer smd 510-3674-390C 026 39 pF ±5% NPO 50V cer smd 510-3674-390C 027 39 pF ±5% NPO 50V cer smd 510-3674-390C 028 39 pF ±5% NPO 50V cer smd 510-3674-390C 029 39 pF ±5% NPO 50V cer smd 510-3674-390 EP 001 Ferrite bead smd 517-2503-002EP 002 Ferrite bead smd 517-2503-002 J 001 Connector, 26-pin ZIF (revised bd) 515-7111-526J 002 Connector, 30-pin 515-7111-430 PC 001 PC board, interconnect 035-5500-050 R 005 0 ohm jumper 569-0165-001R 007 0 ohm jumper 569-0165-001R 008 0 ohm jumper 569-0165-001 VHF 15W PA BOARD ASSEMBLY Part No. nr3-4315-513 C 001 .01 µF X7R ±10% chp 510-3605-103C 002 .1 µF X7R ±10% chip 510-3606-104C 003 .018 µF X7R ±10% chp 510-3605-183C 004 330 pF NPO ±5% chp 510-3601-331C 005 .01 µF X7R ±10% chp 510-3605-103C 006 330 pF NPO ±5% chp 510-3601-331C 007 330 pF NPO ±5% chp 510-3601-331C 008 330 pF NPO ±5% chp 510-3601-331C 009 330 pF NPO ±5% chp 510-3601-331C 010 330 pF NPO ±5% chp 510-3601-331C 011 330 pF NPO ±5% chp 510-3601-331C 012 330 pF NPO ±5% chp 510-3601-331C 013 330 pF NPO ±5% chp 510-3601-331C 014 330 pF NPO ±5% chp 510-3601-331C 015 Capacitor, 10 pF, 1%, high Q, 0805 510-3661-100C 016 .01 µF X7R ±10% chp 510-3605-103C 017 .01 µF X7R ±10% chp 510-3605-103C 018 330 pF NPO ±5% chp 510-3601-331C 019 330 pF NPO ±5% chp 510-3601-331C 020 330 pF NPO ±5% chp 510-3601-331C 021 330 pF NPO ±5% chp 510-3601-331C 022 330 pF NPO ±5% chp 510-3601-331C 023 470 µF 16V LOW ESR 100 kHZ 510-4056-471C 024 330 pF NPO ±5% chp 510-3601-331C 025 .018 µF X7R ±10% chp 510-3605-183C 026 .018 µF X7R ±10% chp 510-3605-183C 027 330 pF NPO ±5% chp 510-3601-331C 028 330 pF NPO ±5% chp 510-3601-331C 029 .0047 µF X7R ±10% chip 510-3606-472C 030 6.8 µF 35V SMD TANT 510-2635-689C 031 330 pF NPO ±5% chp 510-3601-331C 032 330 pF NPO ±5% chp 510-3601-331C 033 .018 µF X7R ±10% chp 510-3605-183
70 C 034 6.8 µF 35V SMD tant 510-2635-689C 035 .001 µF ±5% chip 510-3602-102C 036 330 pF NPO ±5% chp 510-3601-331C 037 .018 µF X7R ±10% chp 510-3605-183C 038 6.8 µF 35V SMD tant 510-2635-689C 039 330 pF NPO ±5% chp 510-3601-331C 040 100 pF NPO ±5% chp 510-3601-101C 041 330 pF NPO ±5% chp 510-3601-331C 042 330 pF NPO ±5% chp 510-3601-331C 044 Capacitor, 6.8 pF, 1%, high Q 510-3661-689C 045 Capacitor, 150 pF, 1%, high Q 510-3661-151C 046 Capacitor, 43 pF, 1%, high Q 510-3661-430C 048 Capacitor, 10 pF, 1%, high Q 510-3661-100C 049 Capacitor, 39 pF, 1%, high Q, 510-3661-390C 050 Capacitor, 240 pF, 1%, high Q 510-3661-241C 051 Capacitor, 240 pF, 1%, high Q 510-3661-241C 054 330 pF NPO ±5% chp 510-3601-331C 055 Capacitor, 22 pF, 1%, high Q SMD 510-3666-220C 056 Capacitor, 15 pF, 1%, high Q SMD 510-3666-150C 057 Capacitor, 22 pF, 1%, high Q SMD 510-3666-220C 058 Capacitor, 240 pF, 1%, high Q 510-3661-241C 059 330 pF NPO ±5% chp 510-3601-331C 060 Capacitor, 10 pF, 1%, high Q SMD 510-3666-100C 061 Capacitor, 10 pF, 1%, high Q SMD 510-3666-100C 062 Capacitor, 330 pF, 1%, high Q SMD 510-3666-331C 063 Capacitor, 12 pF, 1%, high Q SMD 510-3666-120C 064 Capacitor, 22 pF, 1%, high Q, 510-3661-220C 065 330 pF NPO ±5% chp 510-3601-331C 066 Capacitor, 18 pF, 1%, high 510-3661-180Q, C 067 330 pF NPO ±5% chp 510-3601-331C 069 330 pF NPO ±5% chp 510-3601-331C 070 100 pF NPO ±5% chp 510-3601-101C 071 330 pF NPO ±5% chp 510-3601-331C 072 .018 µF X7R ±10% chp 510-3605-183C 073 330 pF NPO ±5% chp 510-3601-331C 074 330 pF NPO ±5% chp 510-3601-331C 075 Capacitor, 33 pF, 1%, high Q 510-3661-330C 076 Capacitor, 18 pF, 1%, high Q 510-3661-180C 077 Capacitor, 18 pF, 1%, high Q 510-3661-180C 078 Capacitor, 180 pF, 1%, high Q 510-3661-181C 079 1500 µF 25V low ESR 100 kHZ 510-4055-152C 082 1 µf 16V chip cap 510-3606-105C 083 10 µF 25V SMD TANT 510-2627-100C 084 1 µf 16V chip cap 510-3606-105C 085 .1 µF X7R ±10% chip 510-3606-104C 086 470 µF 16V low ESR 100 kHZ 510-4056-471C 087 .018 µF X7R ±10% chp 510-3605-183C 088 330 pF NPO ±5% chp 510-3601-331C 089 1 µf 16V chip cap 510-3606-105C 090 470 µF 16V low ESR 100 kHZ 510-4056-471C 091 1 µf 16V chip cap 510-3606-105C 092 330 pF NPO ±5% chp 510-3601-331C 093 330 pF NPO ±5% chp 510-3601-331C 095 1 µf 16V chip cap 510-3606-105C 096 Capacitor, 10 pF, 1%, HIGH Q, 0805 510-3661-100C 097 Capacitor, 10 pF, 1%, HIGH Q, 0805 510-3661-100C 098 Capacitor, 4.7 pF, 1%, HIGH Q, 0805 510-3661-479C 099 Capacitor, 15 pF, 1%, HIGH Q, 0805 510-3661-150C 100 Capacitor, 13 pF, 1%, HIGH Q SURFACE MOUNT 510-3666-130C 230 .1 µF X7R ±10% chip 510-3606-104
71 C 560 1 µf 16V chip cap 510-3606-105 CR 001 Switching diode SOT-23 523-1504-002CR 002 Switching diode SOT-23 523-1504-002CR 003 Switching diode SOT-23 523-1504-002CR 004 Diode, HIPAX PIN 523-1504-036CR 005 Diode, HIPAX PIN 523-1504-036CR 006 Diode, HIPAX PIN 523-1504-036CR 007 Diode, HIPAX PIN 523-1504-036CR 008 HC diode SOT-23 523-1504-016CR 009 Diode, HIPAX PIN 523-1504-036CR 010 Diode, 1 amp SMD fast recovery 523-1600-001CR 011 Diode, SOT PIN SW 523-1504-001CR 012 Diode, HIPAX PIN 523-1504-036CR 014 Zener overvoltage transient suppressor 523-2907-016CR 015 Diode, SOT PIN SW 523-1504-001 D 001 Diode, 5 amp SMD fast recovery 523-1601-550 J 001 Conn 2O POS bot entry SFMT 515-7111-230J 002 SMT Receptacle MMS 515-7111-470J 003 SMT Receptacle MMS 515-7111-470 L 001 330 nH 0805 SMD 10% inductor 542-9003-338L 002 10 nH 0805 SMD 10% inductor 542-9003-107L 003 330 nH 0805 SMD 10% inductor 542-9003-338L 004 10 nH 0805 SMD 10% inductor 542-9003-107L 005 Ferrite bead SMD 517-2503-010L 006 Ferrite bead SMD 517-2503-010L 007 8T .120-in id air die SMD inductor 542-0020-058L 008 33 nH SMD 10% inductor 542-9003-337L 009 330 nH SMD 10% inductor 542-9003-338L 010 330 nH 0805 SMD 10% inductor 542-9003-338L 011 2T .230” ID air die SMD inductor 016-0020-082L 012 2T .230” ID air die SMD inductor 016-0020-082L 013 2T .230” ID air die SMD inductor 016-0020-082L 016 9700 DC line filter, field-installed 542-5010-003L 018 330 nH 0805 SMD 10% inductor 542-9003-338L 019 220 nH 0805 SMD 10% inductor 542-9003-228L 020 39 nH 0805 SMD 10% inductor 542-9003-397L 021 3T .080-in ID air die SMD inductor 18 AWG 542-0020-033L 022 3T .080-in ID air die SMD inductor 18 AWG 542-0020-033L 080 330 nH 0805 SMD 10% inductor 542-9003-338 Q 001 XSTR, switching PNP 576-0003-612Q 002 XSTR,3904,SI,NPN SOT-23(T&R) 576-0003-658Q 003 XSTRSI, NPN SOT-23 576-0003-658Q 004 XSTR, switching PNP 576-0003-612Q 005 XSTR, SI, NPN SOT-23 576-0003-658Q 006 LDMOS 35-W VHF/UHF 12.5-V FET 576-0006-453Q 007 XSTR, SI, NPN SOT-23 576-0003-658Q 008 PNP power Darlington XSTR TO-220 576-0007-013Q 009 XSTR, SI, NPN SOT-23 576-0003-658Q 010 XSTR, switching PNP 576-0003-612 R 001 20k ohm ±5% chip 569-0105-203R 002 20k ohm ±5% chip 569-0105-203R 003 10k ohm ±5% chip 569-0105-103R 004 20k ohm ±5% chip 569-0105-203R 005 10k ohm ±5% chip 569-0105-103R 006 20k ohm ±5% chip 569-0105-203
72 R 007 10k ohm ±5% chip 569-0105-103R 008 4.3k ohm ±5% chip 569-0105-432R 009 20k ohm ±5% chip 569-0105-203R 010 10k ohm ±5% chip 569-0105-103R 011 100K ohm 1% SMD resistor 569-0101-501R 012 20k ohm ±5% chip 569-0105-203R 013 10k ohm ±5% chip 569-0105-103R 015 10k ohm ±5% chip 569-0105-103R 016 20k ohm ±5% chip 569-0105-203R 017 10k ohm ±5% chip 569-0105-103R 018 20k ohm ±5% chip 569-0105-203R 019 Zero ohm ±5% SMD 569-0115-001R 020 100k ohm ±5% chip 569-0105-104R 021 47k ohm ±5% chip 569-0105-473R 022 2.2k ohm ±5% chip 569-0105-222R 024 1.8k ohm ±5% chip 569-0105-182R 025 120 ohm ±5% chip 569-0105-121R 026 1.0k ohm ±5% chip 569-0105-102R 027 7.5k ohm ±5% chip 569-0105-752R 028 10k ohm ±5% chip 569-0105-103R 029 10k ohm ±5% chip 569-0105-103R 031 1.8k ohm ±5% chip 569-0105-182R 032 51 ohm ±5% SMD 569-0175-510R 033 .015 ohm 2W 5% 569-2019-157R 034 47k ohm ±5% chip 569-0105-473R 035 510 ohm ±5% chip 569-0105-511R 036 47k ohm ±5% chip 569-0105-473R 037 4.3k ohm ±5% chip 569-0105-432R 038 51 ohm ±5% smd 569-0175-510R 039 620 ohm ±5% chip 569-0105-621R 040 47k ohm ±5% chip 569-0105-473R 042 47k ohm ±5% chip 569-0105-473R 043 220 ohm ±5% chip 569-0105-221R 044 1.2k ohm ±5% chip 569-0105-122R 045 100 ohm ±5% chip 569-0105-101R 046 100 ohm ±5% chip 569-0105-101R 047 100 ohm ±5% chip 569-0105-101R 048 100 ohm ±5% chip 569-0105-101R 049 100 ohm ±5% chip 569-0105-101R 050 100 ohm ±5% chip 569-0105-101R 051 1.0k ohm ±5% chip 569-0105-102R 052 200 ohm ±5% chip 569-0105-201R 053 220k ohm ±5% chip 569-0105-224R 054 220k ohm ±5% chip 569-0105-224R 055 100k ohm ±5% chip 569-0105-104R 056 100 ohm ±5% chip 569-0105-101R 057 100 ohm ±5% 0.75-W SMD 569-0135-101R 058 220k ohm ±5% chip 569-0105-224R 059 510 ohm ±5% chip 569-0105-511R 060 510 ohm ±5% chip 569-0105-511R 061 220k ohm ±5% chip 569-0105-224R 062 51 ohm ±5% 1-W SMD 569-0175-510R 063 68k ohm ±5% chip 569-0105-683R 064 47k ohm ±5% chip 569-0105-473R 065 47k ohm ±5% chip 569-0105-473R 066 100k ohm ±5% chip 569-0105-104R 067 560 ohm ±5% chip 569-0105-561R 068 47k ohm ±5% chip 569-0105-473R 069 100 ohm ±5% chip 569-0105-101R 070 1.2k ohm ±5% smd 569-0115-122R 071 1.2k ohm ±5% smd 569-0115-122R 072 1.2k ohm ±5% smd 569-0115-122R 073 560 ohm ±5% chip 569-0105-561R 074 510 ohm ±5% chip 569-0105-511R 270 220k ohm ±5% chip 569-0105-224R 370 5.1k ohm ±5% chip 569-0105-512 TR 001 Chip therm 10k ohm ±5% 569-3013-007 U 001 Shift reg. 8-STG SOIC 544-3016-094U 002 Dual op amp SO-8 544-2019-004U 003 AMP, HI-side current sense, SO-8 544-2039-002U 004 Regulator, adjustable, 5 amp 544-2500-001
73 LOGIC BOARD ASSEMBLY Part No. 023-5500-600 A 001 SEM encryption module 023-5000-980 C 001 .01 µF ±10% X7R 25V cer smd 510-3675-103C 013 .1 µF ±10% X7R 25V cer smd 510-3675-104C 014 .1 µF ±10% X7R 25V cer smd 510-3675-104C 052 33pF ±10% 10V cer smd 510-3681-330C 053 33pF ±10% 10V cer smd 510-3681-330C 054 33pF ±10% 10V cer smd 510-3681-330C 055 33pF ±10% 10V cer smd 510-3681-330C 056 33pF ±10% 10V cer smd 510-3681-330C 057 33pF ±10% 10V cer smd 510-3681-330C 058 0.01 µF ±10% 10V cer smd 510-3681-103C 064 0.1 µF +80-20% Z5U 25V cer smd 510-3680-104C 065 0.01 ±10% 10V cer smd 510-3681-103C 066 2.2 µF 16V ceramic smd 510-3925-225C 069 0.1 µF+80-20% Z5U 25V cer smd 510-3680-104C 070 0.01 µF ±10% 10V cer smd 510-3681-103C 071 2.2 µF 16V ceramic smd 510-3925-225C 078 2.2 µF 16V ceramic smd 510-3925-225C 079 1 µF +80-20% Z5U 25V cer smd 510-3631-105C 080 .01 µF ±10% 10V cer smd 510-3681-103C 081 1.5F electrolytic 510-9510-057C 125 .1 µF ±10% X7R 25V cer smd 510-3675-104C 126 .01 µF ±10% 10V cer smd 510-3681-103C 127 .01 µF ±10% 10V cer smd 510-3681-103C 128 .01 µF ±10% 10V cer smd 510-3681-103C 129 .01 µF ±10% 10V cer smd 510-3681-103C 130 .01 µF ±10% 10V cer smd 510-3681-103C 131 .01 µF ±10% 10V cer smd 510-3681-103C 183 .01 µF ±10% 10V cer smd 510-3681-103C 184 .01 µF ±10% 10V cer smd 510-3681-103C 185 .01 µF ±10% 10V cer smd 510-3681-103C 186 .01 µF ±10% 10V cer smd 510-3681-103C 190 .01 µF ±10% 10V cer smd 510-3681-103C 191 .01 µF ±10% 10V cer smd 510-3681-103C 192 .01 µF ±10% 10V cer smd 510-3681-103C 196 .1 µF ±10% X7R 25V cer smd 510-3675-104C 197 .1 µF ±10% X7R 25V cer smd 510-3675-104C 198 .1 µF ±10% X7R 25V cer smd 510-3675-104C 199 .1 µF ±10% X7R 25V cer smd 510-3675-104C 200 .01 µF ±10% X7R 25V cer smd 510-3675-104C 201 .1 µF ±10% X7R 25V cer smd 510-3675-104C 202 .1 µF ±10% X7R 25V cer smd 510-3675-104C 203 .1 µF ±10% X7R 25V cer smd 510-3675-104C 204 .1 µF ±10% X7R 25V cer smd 510-3675-104C 205 .1 µF ±10% X7R 25V cer smd 510-3675-104C 206 .1 µF ±10% X7R 25V cer smd 510-3675-104C 207 .1 µF ±10% X7R 25V cer smd 510-3675-104C 208 .1 µF ±10% X7R 25V cer smd 510-3675-104C 209 .1 µF ±10% X7R 25V cer smd 510-3675-104C 210 .1 µF ±10% X7R 25V cer smd 510-3675-104C 211 .1 µF ±10% X7R 25V cer smd 510-3675-104C 212 .01 µF ±10% 10V cer smd 510-3681-103C 213 .01 µF ±10% 10V cer smd 510-3681-103C 214 .01 µF ±10% 10V cer smd 510-3681-103C 215 .01 µF ±10% 10V cer smd 510-3681-103C 216 .01 µF ±10% 10V cer smd 510-3681-103
74 C 217 .01 µF ±10% 10V cer smd 510-3681-103C 218 .01 µF ±10% 10V cer smd 510-3681-103C 219 .01 µF ±10% 10V cer smd 510-3681-103C 220 .01 µF ±10% 10V cer smd 510-3681-103C 221 .01 µF ±10% 10V cer smd 510-3681-103C 222 .01 µF ±10% 10V cer smd 510-3681-103C 223 .01 µF ±10% 10V cer smd 510-3681-103C 224 .01 µF ±10% 10V cer smd 510-3681-103C 225 .01 µF ±10% 10V cer smd 510-3681-103C 226 10 µF 10V cer smd 510-3755-106C 227 .1 µF ±10% X7R 25V cer smd 510-3675-104C 228 3300 pF ±10% 10V cer smd 510-3681-332C 229 56 pF ±5% 50V cer smd 510-3684-560C 230 47 pF ±10% cer smd 510-3681-470C 231 1 µF ±20% Z5U 25V cer smd 510-3636-105C 232 1 µF ±20% Z5U 25V cer smd 510-3636-105C 233 220 pF ±5% NPO 25V cer smd 510-3674-221C 234 470 pF ±5% NPO 25V cer smd 510-3674-471C 235 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 236 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 237 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 238 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 239 1 µF ±20% Z5U 25V cer smd 510-3636-105C 240 1 µF ±20% Z5U 25V cer smd 510-3636-105C 241 220 pF ±5% NPO 25V cer smd 510-3674-221C 242 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 243 100 pF ±5% NPO 25V cer smd 510-3674-101C 245 1 µF ±20% Z5U 25V cer smd 510-3636-105C 246 1 µF ±20% Z5U 25V cer smd 510-3636-105C 247 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 248 4700 pF 10% X7R 25V cer smd 510-3675-472C 249 470 pF ±5% NPO 25V cer smd 510-3674-471C 250 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 251 220 pF ±5% NPO 25V cer smd 510-3674-221C 252 220 pF ±5% NPO 25V cer smd 510-3674-221C 253 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 254 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 255 10 µF 10V tantalum smd 510-2624-100C 257 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 258 10 µF 10V tantalum smd 510-2624-100C 261 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 262 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 263 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 263 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 264 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 265 .1 µF +80-20% Z5U 25V cer smd 510-3680-104C 266 470 pF ±5% NPO 25V cer smd 510-3674-471C 267 470 pF ±5% NPO 25V cer smd 510-3674-471C 268 470 pF ±5% NPO 25V cer smd 510-3674-471C 269 470 pF ±5% NPO 25V cer smd 510-3674-471C 270 470 pF ±5% NPO 25V cer smd 510-3674-471C 271 470 pF ±5% NPO 25V cer 510-3674-471
75 smd C 272 470 pF ±5% NPO 25V cer smd 510-3674-471C 273 470 pF ±5% NPO 25V cer smd 510-3674-471C 274 470 pF ±5% NPO 25V cer smd 510-3674-471C 275 470 pF ±5% NPO 25V cer smd 510-3674-471C 276 470 pF ±5% NPO 25V cer smd 510-3674-471C 277 470 pF ±5% NPO 25V cer smd 510-3674-471C 278 470 pF ±5% NPO 25V cer smd 510-3674-471C 279 470 pF ±5% NPO 25V cer smd 510-3674-471C 281 470 pF ±5% NPO 25V cer smd 510-3674-471C 282 470 pF ±5% NPO 25V cer smd 510-3674-471C 283 470 pF ±5% NPO 25V cer smd 510-3674-471C 284 470 pF ±5% NPO 25V cer smd 510-3674-471C 285 470 pF ±5% NPO 25V cer smd 510-3674-471C 286 470 pF ±5% NPO 25V cer smd 510-3674-471C 287 470 pF ±5% NPO 25V cer smd 510-3674-471C 288 470 pF ±5% NPO 25V cer smd 510-3674-471C 289 470 pF ±5% NPO 25V cer smd 510-3674-471C 290 470 pF ±5% NPO 25V cer smd 510-3674-471C 291 470 pF ±5% NPO 25V cer smd 510-3674-471C 292 470 pF ±5% NPO 25V cer smd 510-3674-471C 293 470 pF ±5% NPO 25V cer smd 510-3674-471C 294 470 pF ±5% NPO 25V cer smd 510-3674-471C 295 470 pF ±5% NPO 25V cer smd 510-3674-471C 296 470 pF ±5% NPO 25V cer smd 510-3674-471C 299 470 pF ±5% NPO 25V cer smd 510-3674-471C 302 470 pF ±5% NPO 25V cer smd 510-3674-471C 303 470 pF ±5% NPO 25V cer smd 510-3674-471C 304 470 pF ±5% NPO 25V cer smd 510-3674-471C 305 470 pF ±5% NPO 25V cer smd 510-3674-471C 306 470 pF ±5% NPO 25V cer smd 510-3674-471C 308 0.01 µF ±10% X7R 25V cer smd 510-3675-103C 309 470 pF ±5% NPO 25V cer smd 510-3674-471C 312 .1 µF ±10% X7R 25V cer smd 510-3675-104C 313 .1 µF ±10% X7R 25V cer smd 510-3675-104C 314 .1 µF ±10% X7R 25V cer smd 510-3675-104C 315 .1 µF ±10% X7R 25V cer smd 510-3675-104C 316 10 µF 10V cer smd 510-3755-106C 317 8.2pF +/-.1pF NPO cer smd 510-3673-829C 318 22 µF ±10% 16V X5R smd 510-3607-226C 319 .1 µF ±10% X7R 25V cer smd 510-3675-104C 320 10 µF 10V cer smd 510-3755-106C 321 10 pF ±.1 pF NPO cer smd 510-3673-100C 322 10 pF ±.1 pF NPO cer smd 510-3673-100C 323 22 µF ±10% 16V X5R smd 510-3607-226C 324 .1 µF ±10% X7R 25V cer smd 510-3675-104C 325 4.7 µF 20V tantalum smd 510-2626-479C 326 0.01 µF ±10% X7R 25V cer smd 510-3675-103C 327 0.01 µF ±10% X7R 25V cer smd 510-3675-103
76 C 328 .01 µF ±10% 10V cer smd 510-3681-103C 329 .01 µF ±10% 10V cer smd 510-3681-103C330 .01 µF ±10% 10V cer smd 510-3681-103C331 .01 µF ±10% 10V cer smd 510-3681-103C332 .1 µF ±10% X7R 25V cer smd 510-3675-104C333 .1 µF ±10% X7R 25V cer smd 510-3675-104C334 .1 µF ±10% X7R 25V cer smd 510-3675-104C335 .01 µF ±10% 10V cer smd 510-3681-103C336 .01 µF ±10% 10V cer smd 510-3681-103C337 .01 µF ±10% 10V cer smd 510-3681-103C338 .1 µF ±10% X7R 25V cer smd 510-3675-104C339 .1 µF ±10% X7R 25V cer smd 510-3675-104C 340 .1 µF ±10% X7R 25V cer smd 510-3675-104C 341 100 pF ±10% 25V cer smd 510-3681-101C 342 100 pF ±10% 25V cer smd 510-3681-101C 343 .01 µF ±10% 10V cer smd 510-3681-103C 344 .01 µF ±10% 10V cer smd 510-3681-103C 345 .01 µF ±10% 10V cer smd 510-3681-103C 346 .01 µF ±10% 10V cer smd 510-3681-103C 347 .01 µF ±10% 10V cer smd 510-3681-103C 348 .01 µF ±10% 10V cer smd 510-3681-103C 349 0.01 µF ±10% X7R 25V cer smd 510-3675-103C 350 .01 µF ±10% 10V cer smd 510-3681-103C 351 2.2 µF 16V cer smd 510-3925-225C 352 .1 µF ±10% X7R 25V cer smd 510-3675-104C 353 .1 µF ±10% X7R 25V cer smd 510-3675-104C 354 .1 µF ±10% X7R 25V cer smd 510-3675-104C 355 .1 µF ±10% X7R 25V cer smd 510-3675-104 CR 001 Silicon switching diode 523-1004-021CR 002 Silicon switching diode 523-1004-021CR 003 Silicon switching diode 523-1004-021CR 004 Zener diode, 5.6V 523-2016-569CR 005 Zener diode, 18V 523-2601-180CR 006 Zener diode, 5.1V 523-2601-519CR 010 Zener diode, 3.6V 523-2016-369CR 011 Zener diode, 3.6V 523-2016-369CR 012 Silicon switching diode 523-1004-021CR 013 LED, green 549-4003-011CR 014 LED, green 549-4003-011CR 015 LED, green 549-4003-011 D 002 Dual switching diode, com cath 523-1504-022D 003 Dual switching diode, com cath 523-1504-022D 004 Dual switching diode, com cath 523-1504-022D 005 Dual switching diode, com cath 523-1504-022D 006 Dual switching diode, com cath 523-1504-022 F 001 Fuse, 0.5A smd 534-5002-009 J 001 Connector, 16-pin 515-7000-668J 002 Connector, 25-pin 515-7113-071J 005 Connector, 13-pin 515-7111-262J 006 Connector, 13-pin 515-7111-262J 007 Connector, 5-pin 515-7111-254J 008 Connector, 12-pin 515-7111-261J 009 Connector, 2 14-pin 515-9500-045J 011 Connector, 5-pin 515-7111-254J 012 Connector, 13-pin 515-7111-262J 016 Connector, 25-pin 515-7113-071J 018 Connector, 25-pin 515-7113-071 L 015 - Inductor, ferrite smd 542-9230-023 L 053 L 054 8.2 µH ±5% smd 542-9000-829
77 L 055 Bead, ferrite smd 542-9230-005L 056 Bead, ferrite smd 542-9230-005L 057 Inductor, ferrite smd 542-9230-021L 058 Inductor, ferrite smd 542-9230-021L 059 Inductor, ferrite smd 542-9230-021L 060 Inductor, ferrite smd 542-9230-021L 061 Inductor, ferrite smd 542-9230-021L 062 Inductor, ferrite smd 542-9230-021L 063 Bead, ferrite smd 542-9230-005L 064 10 µH power inductor 542-9009-100L 065 10 µH power inductor 542-9009-100 PC 001 PC board, 5500 logic rev 1 035-5500-600 1 Q 005 N-chan MOSFET 60V 1A 576-0003-725Q 006 NPN general purpose 576-0003-658Q 009 NPN general purpose 576-0003-658Q 010 NPN general purpose 576-0003-658Q 011 NPN general purpose 576-0003-658Q 012 NPN general purpose 576-0003-658Q 013 NPN general purpose 576-0003-658Q 014 NPN general purpose 576-0003-658Q 015 NPN general purpose 576-0003-658Q 017 NPN general purpose 576-0003-658Q 018 NPN general purpose 576-0003-658Q 020 NPN general purpose 576-0003-658Q 021 NPN general purpose 576-0003-658Q 022 NPN general purpose 576-0003-658Q 023 NPN general purpose 576-0003-658Q 024 NPN general purpose 576-0003-658Q 025 NPN general purpose 576-0003-658Q 026 NPN general purpose 576-0003-658Q 027 NPN general purpose 576-0003-658Q 028 NPN general purpose 576-0003-658Q 029 NPN general purpose 576-0003-658 R 001 10k ohm ±5% 1/16W smd 569-0165-103R 002 51k ohm ±5% 1/16W smd 569-0165-513R 003 51k ohm ±5% 1/16W smd 569-0165-513R 004 51k ohm ±5% 1/16W smd 569-0165-513R 006 4.7k ohm ±5% 1/16W smd 569-0165-472R 007 4.7k ohm ±5% 1/16W smd 569-0165-472R 008 4.7k ohm ±5% 1/16W smd 569-0165-472R 009 4.7k ohm ±5% 1/16W smd 569-0165-472R 010 4.7k ohm ±5% 1/16W smd 569-0165-472R 011 4.7k ohm ±5% 1/16W smd 569-0165-472R 012 4.7k ohm ±5% 1/16W smd 569-0165-472R 013 4.7k ohm ±5% 1/16W smd 569-0165-472R 014 4.7k ohm ±5% 1/16W smd 569-0165-472R 015 4.7k ohm ±5% 1/16W smd 569-0165-472R 016 4.7k ohm ±5% 1/16W smd 569-0165-472R 017 4.7k ohm ±5% 1/16W smd 569-0165-472R 018 100k ohm ±5% 1/16W smd 569-0165-104R 019 4.7k ohm ±5% 1/16W smd 569-0165-472R 020 4.7k ohm ±5% 1/16W smd 569-0165-472R 021 4.7k ohm ±5% 1/16W smd 569-0165-472R 022 4.7k ohm ±5% 1/16W smd 569-0165-472R 023 4.7k ohm ±5% 1/16W smd 569-0165-472R 024 4.7k ohm ±5% 1/16W smd 569-0165-472R 025 4.7k ohm ±5% 1/16W smd 569-0165-472R 029 51k ohm ±5% 1/16W smd 569-0165-513R 030 51k ohm ±5% 1/16W smd 569-0165-513R 031 51k ohm ±5% 1/16W smd 569-0165-513R 038 47k ohm ±5% 1/16W smd 569-0155-473R 039 47k ohm ±5% 1/16W smd 569-0155-473R 040 620 ohm ±5% smd 569-0105-621R 041 620 ohm ±5% smd 569-0105-621R 076 100 ohm ±5% 1/16W smd 569-0165-101R 078 10 ohm ±5% 1/16W smd 569-0165-100R 080 1k ohm ±5% 1/16W smd 569-0155-102R 095 220k ohm ±5% 1/16W smd 569-0155-224R 098 10k ohm ±5% 1/16W smd 569-0155-103R 099 10k ohm ±5% 1/16W smd 569-0155-103R 100 10k ohm ±5% 1/16W smd 569-0155-103R 101 4.7k ohm ±5% 1/16W smd 569-0165-472
78 R 102 4.7k ohm ±5% 1/16W smd 569-0165-472R 103 100k ohm ±5% 1/16W smd 569-0165-104R 104 100k ohm ±5% 1/16W smd 569-0165-104R 105 220k ohm ±5% 1/16W smd 569-0165-224R 106 220k ohm ±5% 1/16W smd 569-0165-224R 107 1k ohm ±5% 1/16W smd 569-0165-102R 108 220k ohm ±5% 1/16W smd 569-0165-224R 109 2k ohm ±5% 1/16W smd 569-0165-202R 110 4.7k ohm ±5% 1/16W smd 569-0165-472R 111 2k ohm ±5% 1/16W smd 569-0165-202R 112 2k ohm ±5% 1/16W smd 569-0165-202R 113 220k ohm ±5% 1/16W smd 569-0165-224R 114 4.7k ohm ±5% 1/16W smd 569-0165-472R 115 220k ohm ±5% 1/16W smd 569-0165-224R 117 220k ohm ±5% 1/16W smd 569-0165-224R 118 220k ohm ±5% 1/16W smd 569-0165-224R 119 220k ohm ±5% 1/16W smd 569-0165-224R 120 220k ohm ±5% 1/16W smd 569-0165-224R 121 220k ohm ±5% 1/16W smd 569-0165-224R 122 220k ohm ±5% 1/16W smd 569-0165-224R 123 220k ohm ±5% 1/16W smd 569-0165-224R 124 220k ohm ±5% 1/16W smd 569-0165-224R 125 220k ohm ±5% 1/16W smd 569-0165-224R 126 220k ohm ±5% 1/16W smd 569-0165-224R 127 220k ohm ±5% 1/16W smd 569-0165-224R 128 220k ohm ±5% 1/16W smd 569-0165-224R 129 220k ohm ±5% 1/16W smd 569-0165-224R 130 220k ohm ±5% 1/16W smd 569-0165-224R 131 220k ohm ±5% 1/16W smd 569-0165-224R 132 4.7k ohm ±5% 1/16W smd 569-0165-472R 141 47k ohm ±5% 1/16W smd 569-0155-473R 224 10k ohm ±5% 1/16W smd 569-0165-103R 225 10k ohm ±5% 1/16W smd 569-0165-103R 226 10k ohm ±5% 1/16W smd 569-0165-103R 249 10k ohm ±5% 1/16W smd 569-0155-103R 251 10k ohm ±5% 1/16W smd 569-0155-103R 252 10 ohm ±5% 1/16W smd 569-0165-100R 253 10 ohm ±5% 1/16W smd 569-0165-100R 255 10 ohm ±5% 1/16W smd 569-0165-100R 256 10 ohm ±5% 1/16W smd 569-0165-100R 257 1k ohm ±5% 1/16W smd 569-0165-102R 258 2k ohm ±5% 1/16W smd 569-0155-202R 259 10M ohm ±5% 1/16W smd 569-0165-106R 260 2k ohm ±5% 1/16W smd 569-0155-202R 261 220k ohm ±5% 1/16W smd 569-0165-224R 262 330 ohm ±5% 1/16W smd 569-0155-331R 263 100k ohm ±5% 1/16W smd 569-0165-104R 264 100k ohm ±5% 1/16W smd 569-0165-104R 265 100k ohm ±5% 1/16W smd 569-0165-104R 266 6.8k ohm ±5% 1/16W smd 569-0155-682R 267 330 ohm ±5% 1/16W smd 569-0155-331R 268 100k ohm ±5% 1/16W smd 569-0165-104R 269 220k ohm ±5% 1/16W smd 569-0165-224R 270 62k ohm ±5% 1/16W smd 569-0155-623R 271 150k ohm ±5% 1/16W smd 569-0155-154R 272 6.8k ohm ±5% 1/16W smd 569-0155-682R 273 6.8k ohm ±5% 1/16W smd 569-0155-682R 274 220k ohm ±5% 1/16W smd 569-0165-224R 275 330 ohm ±5% 1/16W smd 569-0155-331R 276 6.8k ohm ±5% 1/16W smd 569-0155-682R 277 100k ohm ±5% 1/16W smd 569-0165-104R 278 100k ohm ±5% 1/16W smd 569-0165-104R 279 100k ohm ±5% 1/16W smd 569-0165-104R 280 330 ohm ±5% 1/16W smd 569-0155-331R 281 220k ohm ±5% 1/16W smd 569-0165-224R 282 0 ohm jumper 569-0155-001R 283 100k ohm ±5% 1/16W smd 569-0165-104R 284 100k ohm ±5% 1/16W smd 569-0155-104R 285 10k ohm ±5% 1/16W smd 569-0155-103R 286 100k ohm ±5% 1/16W smd 569-0165-104R 287 20k ohm ±5% 1/16W smd 569-0155-203R 288 56k ohm ±5% 1/16W smd 569-0155-563R 289 390k ohm ±5% 1/16W smd 569-0155-394R 290 6.8k ohm ±5% 1/16W smd 569-0155-682R 291 47k ohm ±5% 1/16W smd 569-0155-473R 292 47k ohm ±5% 1/16W smd 569-0155-473
79 R 293 6.8k ohm ±5% 1/16W smd 569-0155-682R 294 100k ohm ±5% 1/16W smd 569-0155-104R 295 150 ohm ±5% 1/16W smd 569-0155-151R 296 6.8k ohm ±5% 1/16W smd 569-0155-682R 297 100k ohm ±5% 1/16W smd 569-0155-104R 298 150 ohm ±5% 1/16W smd 569-0155-151R 299 6.8k ohm ±5% 1/16W smd 569-0155-682R 300 100k ohm ±5% 1/16W smd 569-0155-104R 301 100k ohm ±5% 1/16W smd 569-0155-104R 302 100k ohm ±5% 1/16W smd 569-0155-104R 303 6.8k ohm ±5% 1/16W smd 569-0155-682R 304 68k ohm ±5% 1/16W smd 569-0165-683R 305 0 ohm jumper 569-0155-001R 307 100k ohm ±5% 1/16W smd 569-0155-104R 308 0 ohm jumper 569-0155-001R 309 100k ohm ±5% 1/16W smd 569-0155-104R 310 6.8k ohm ±5% 1/16W smd 569-0155-682R 311 100k ohm ±5% 1/16W smd 569-0155-104R 312 100k ohm ±5% 1/16W smd 569-0155-104R 313 100k ohm ±5% 1/16W smd 569-0155-104R 315 10k ohm ±5% 1/16W smd 569-0155-103R 316 47k ohm ±5% 1/16W smd 569-0155-473R 318 10k ohm ±5% 1/16W smd 569-0155-103R 319 47k ohm ±5% 1/16W smd 569-0155-473R 320 10k ohm ±5% 1/16W smd 569-0155-103R 321 10k ohm ±5% 1/16W smd 569-0155-103R 322 10k ohm ±5% 1/16W smd 569-0155-103R 323 1k ohm ±5% 1/16W smd 569-0155-102R 324 10k ohm ±5% 1/16W smd 569-0155-103R 325 10k ohm ±5% 1/16W smd 569-0155-103R 326 10k ohm ±5% 1/16W smd 569-0155-103R 327 10k ohm ±5% 1/16W smd 569-0155-103R 328 10k ohm ±5% 1/16W smd 569-0155-103R 329 100 ohm ±5% 1/16W smd 569-0155-101R330 10k ohm ±5% 1/16W smd 569-0155-103R331 10k ohm ±5% 1/16W smd 569-0155-103R332 470 ohm ±5% 1/16W smd 569-0155-471R333 10k ohm ±5% 1/16W smd 569-0155-103R334 47k ohm ±5% 1/16W smd 569-0155-473R336 100 ohm ±5% 1/16W smd 569-0155-101R338 10k ohm ±5% 1/16W smd 569-0155-103R339 10k ohm ±5% 1/16W smd 569-0155-103R 340 47k ohm ±5% 1/16W smd 569-0155-473R 344 10k ohm ±5% 1/16W smd 569-0155-103R 345 470 ohm ±5% 1/16W smd 569-0155-471R 346 10k ohm ±5% 1/16W smd 569-0155-103R 348 10k ohm ±5% 1/16W smd 569-0155-103R 350 10k ohm ±5% 1/16W smd 569-0155-103R 351 47k ohm ±5% 1/16W smd 569-0155-473R 353 10k ohm ±5% 1/16W smd 569-0155-103R 355 47k ohm ±5% 1/16W smd 569-0155-473R 356 10k ohm ±5% 1/16W smd 569-0155-103R 357 100 ohm ±5% 1/16W smd 569-0155-101R 358 100 ohm ±5% 1/16W smd 569-0155-101R 360 10 ohm ±5% 1/16W smd 569-0155-100R 361 47k ohm ±5% 1/16W smd 569-0155-473R 362 4.7k ohm ±5% 1/16W smd 569-0155-472R 364 10k ohm ±5% 1/16W smd 569-0155-103R 365 10k ohm ±5% 1/16W smd 569-0155-103R 366 100k ohm ±5% 1/16W smd 569-0155-104R 367 47k ohm ±5% 1/16W smd 569-0155-473R 368 10k ohm ±5% 1/16W smd 569-0155-103R 369 10k ohm ±5% 1/16W smd 569-0155-103R 370 1k ohm ±5% 1/16W smd 569-0155-102R 371 10k ohm ±5% 1/16W smd 569-0155-103R 372 100k ohm ±5% 1/16W smd 569-0155-104R 373 33.2k ohm ±1% 0.1W smd 569-0151-451R 374 10k ohm ±5% 1/16W smd 569-0155-103R 377 10k ohm ±5% 1/16W smd 569-0155-103R 378 10k ohm ±5% 1/16W smd 569-0155-103R 379 10k ohm ±5% 1/16W smd 569-0155-103R 392 10k ohm ±5% 1/16W smd 569-0155-103R 393 10k ohm ±5% 1/16W smd 569-0155-103R 394 10k ohm ±5% 1/16W smd 569-0155-103R 395 10k ohm ±5% 1/16W smd 569-0155-103R 396 10k ohm ±5% 1/16W smd 569-0155-103
80 R 399 100k ohm ±5% 1/16W smd 569-0165-104R 400 634k ohm ±1% 0.1W smd 569-0151-578R 401 100k ohm ±1% 0.1W smd 569-0151-501R 402 100k ohm ±5% 1/16W smd 569-0165-104R 403 255k ohm ±1% 0.1W smd 569-0151-551R 404 100k ohm ±1% 0.1W smd 569-0151-501R 405 10k ohm ±5% 1/16W smd 569-0155-103R 406 10k ohm ±5% 1/16W smd 569-0155-103R 407 10k ohm ±5% 1/16W smd 569-0155-103R 408 10k ohm ±5% 1/16W smd 569-0155-103R 409 10k ohm ±5% 1/16W smd 569-0155-103R 410 10k ohm ±5% 1/16W smd 569-0155-103R 412 100k ohm ±5% 1/16W smd 569-0165-104R 413 100k ohm ±5% 1/16W smd 569-0165-104R 683 68k ohm ±5% 1/16W smd 569-0155-683R 685 27k ohm ±5% 1/16W smd 569-0155-273R 686 100k ohm ±5% 1/16W smd 569-0165-104R 687 100k ohm ±5% 1/16W smd 569-0165-104R 688 51k ohm ±5% 1/16W smd 569-0165-513R 689 100k ohm ±5% 1/16W smd 569-0165-104R 690 100k ohm ±5% 1/16W smd 569-0165-104R 691 100k ohm ±5% 1/16W smd 569-0165-104R 692 4.7k ohm ±5% 1/16W smd 569-0165-472R 693 4.7k ohm ±5% 1/16W smd 569-0165-472R 694 10k ohm ±5% 1/16W smd 569-0165-103R 695 10k ohm ±5% 1/16W smd 569-0165-103R 696 10k ohm ±5% 1/16W smd 569-0165-103R 697 10k ohm ±5% 1/16W smd 569-0165-103R 698 4.7k ohm ±5% 1/16W smd 569-0165-472R 699 10k ohm ±5% 1/16W smd 569-0165-103R 700 10k ohm ±5% 1/16W smd 569-0165-103R 701 15k ohm ±5% 1/16W smd 569-0165-153R 702 20k ohm ±5% 1/16W smd 569-0165-203R 703 30k ohm ±5% 1/16W smd 569-0155-303R 704 10k ohm ±5% 1/16W smd 569-0165-103R 705 15k ohm ±5% 1/16W smd 569-0165-153R 706 20k ohm ±5% 1/16W smd 569-0165-203R 707 30k ohm ±5% 1/16W smd 569-0155-303R 709 1k ohm ±5% 1/16W smd 569-0165-102R 710 1k ohm ±5% 1/16W smd 569-0165-102R 711 1k ohm ±5% 1/16W smd 569-0165-102R 712 1k ohm ±5% 1/16W smd 569-0165-102R 713 10k ohm ±5% 1/16W smd 569-0165-103R 714 10k ohm ±5% 1/16W smd 569-0165-103R 715 10k ohm ±5% 1/16W smd 569-0165-103R 716 1k ohm ±5% 1/16W smd 569-0165-102R 717 1k ohm ±5% 1/16W smd 569-0165-102R 718 1k ohm ±5% 1/16W smd 569-0165-102R 719 1k ohm ±5% 1/16W smd 569-0165-102R 720 1k ohm ±5% 1/16W smd 569-0165-102R 721 1k ohm ±5% 1/16W smd 569-0165-102R 722 4.7k ohm ±5% 1/16W smd 569-0165-472R 723 4.7k ohm ±5% 1/16W smd 569-0165-472R 724 15k ohm ±5% 1/16W smd 569-0165-153R 725 18k ohm ±5% 1/16W smd 569-0165-183R 726 180 ohm ±5% 1/16W smd 569-0165-181R 727 180 ohm ±5% 1/16W smd 569-0165-181R 728 180 ohm ±5% 1/16W smd 569-0165-181R 729 10k ohm ±5% 1/16W smd 569-0165-103R 730 24 ohm ±5% 1/16W smd 569-0165-240R 731 24 ohm ±5% 1/16W smd 569-0165-240R 732 100k ohm ±5% 1/16W smd 569-0165-104R 733 7.5k ohm ±1% 1/8W smd 569-0111-385R 734 7.5k ohm ±1% 1/8W smd 569-0111-385R 735 10k ohm ±5% 1/16W smd 569-0165-103R 736 10k ohm ±5% 1/16W smd 569-0165-103R 737 10k ohm ±5% 1/16W smd 569-0165-103R 738 51 ohm ±5% 1/16W smd 569-0155-510R 739 51 ohm ±5% 1/16W smd 569-0155-510R 740 10k ohm ±5% 1/16W smd 569-0155-103R 741 100k ohm ±5% 1/16W smd 569-0165-104R 742 100k ohm ±5% 1/16W smd 569-0165-104R 744 0 ohm jumper 569-0165-001R 745 0 ohm jumper 569-0165-001R 746 0 ohm jumper 569-0165-001R 747 0 ohm jumper 569-0165-001
81 R 748 10 ohm ±5% 1/16W smd 569-0165-100R 749 10 ohm ±5% 1/16W smd 569-0165-100R 752 10k ohm ±5% 1/16W smd 569-0165-103R 753 10k ohm ±5% 1/16W smd 569-0165-103 S 001 Switch, momentary norm open 583-9512-002 T 001 Isolation transformer 10BASE-T 592-9017-003 U 001 DSP TMS3205510AGGWA1 544-5003-133U 002 CODEC, dual TLV320AIC211 544-3016-057U 003 Schmitt trig, inv TC7S14F-TE85L 544-3123-014U 004 Op Amp OPA340NA 544-2020-023U 011 Regulator, 5V 400mA REG113EA-5 544-2603-055U 013 Regulator, 5V 400mA REG113EA-5 544-2603-055U 015 Regulator, 3.8V, 50 mA LP2982 544-5001-335U 020 SRAM 256k x 16 CY62146V 544-5001-213U 021 Flash, 8M X 8 bit AM29DL640G90 544-5001-255U 022 Buffer, quad 74LCX125 544-3776-127U 023 SRAM 512k x 16 CY62157CV30 544-5001-215U 024 Tri state buffer, 3.3V NC7SZ125P5 544-3914-125U 025 Buffer, quad 74LCX125 544-3776-127U 026 3-state buffer, quad 74ACT125 544-3776-117U 027 Schmitt trig, inv TC7S14F-TE85L 544-3123-014U 042 Triple supply monitor LT1727 544-5001-341U 045 RS-232 bus xcvr MAX3221EAE 544-2023-036U 046 RS-485 bus transceiver ADM483 544-2023-073U 048 Bus xcvr, octal 74LVCC3245 544-1010-250U 049 Op am, quad MC3303 544-2020-008U 056 Multiplexer triple 4053 544-1014-053U 057 Microcontroller PowerPC MPC850 544-5003-127U 058 EEPROM 32k x 8 M24256 544-1019-376U 059 Multiplexer triple 4053 544-1014-053U 060 Op am, quad MC3303 544-2020-008U 061 Op am, quad MC3303 544-2020-008U 063 Flip flop octal 74HC574 544-3764-576U 064 Flip flop octal 74HC574 544-3764-576U 065 Flip flop octal 74HC574 544-3764-576U 066 Multiplexer triple 4053 544-1014-053U 067 Converter, A/D 8-bit ser TLC5481 544-1010-548U 069 RS-232 bus xcvr MAX3221EAE 544-2023-036U 070 Analog switch, SPDT NLAS4599 544-4002-007U 071 SRAM 512k x 16 CY62157CV30 544-5001-215U 072 SRAM 512k x 16 CY62157CV30 544-5001-215U 073 Tri state buffer, 3.3V NC7SZ125P5 544-3914-125U 074 DC-DC converter TPS6200 544-4006-011U 075 DC-DC converter TPS6200 544-4006-011U 079 Tri state buffer, 3.3V NC7SZ125P5 544-3914-125U 080 Regulator 5V LT1121IST-5 544-1011-121U 081 Buffer, quad 74LCX125 544-3776-127U 082 Programmable logic 544-5001-419U 083 Op amp, quad OPA4340EA 544-2020-013U 084 Op amp, quad OPA4340EA 544-2020-013U 085 Transceiver, 10BASE-T 3V 544-2023-050U 086 Reg, 3.3V 400 mA REG113EA-3.3 544-2603-056U 087 Op amp, quad OPA4340EA 544-2020-013 Y 002 Crystal, 4.9152 MHz smd 521-3060-022
82 Y 003 TCXO, 12.288 MHz smd 518-7012-200Y 004 Oscillator, 20.000 MHz smd 561-9004-200 FRONT PANEL ASSEMBLY Part No. 023-5300-810 A 151 Plastic front panel assembly 587-9650-002A 815 Display controller board 023-5300-813 (see separate listings) C 750 4.7 µF 10V tantalum smd 510-2624-479C 754 1.0 µF 35V tantalum smd 510-2628-109C 755 4.7 µF 10V tantalum smd 510-2624-479 DS 700 Dual color, red/grn LED 549-4001-215DS 701- DS706 LED, green smd 549-4001-145DS 707- DS726 LED, green smd 549-4003-011DS 727 LCD assembly 549-4501-010EP 101 Key cap kit (see Section 2.8) 587-5300-001 HW 010 Washer, .438 x .274 x .030 596-9410-010HW 011 Nut, spanner 3/8 x 7mm 013-1313-018HW 012 Screw, 2-56 x 1/4 575-1602-008HW 013 Lockwasher, internal No. 2 596-2102-006 J 703 Connector, 13-pin circular recept 515-1009-025J 705 Connector, 31-pin 515-7109-129 LS 001 Speaker, 2 x 3 in 16-ohm 589-1015-006 MP 101 Display bezel 017-2226-046MP 102 Display gasket 018-1136-120MP 103 Light pipe 032-0792-032MP 108 Support-keypad 017-2226-090MP 151 Gasket, front lens 018-1136-130MP 152 Control knob 032-0792-010MP 153 Control knob 032-0792-010MP 154 Speaker membrane 018-1136-138MP 155 Spacer, display board 018-1136-140MP 158 Front panel lens 032-0792-034MP 160 Spacer (between boards) 013-1188-053MP 161 Keypad, standard 032-0792-031MP 162 Speaker retainer 016-2187-250MP 163 Speaker gasket, silicone 018-1136-128MP 990 Gasket, microphone jack silicone 018-1136-132 NP 001 Johnson label raised 559-9001-310NP 002 Label, RS 5300 559-5300-100PC 010 Flex circuit, std push on-off 035-5300-010 Flex circuit, motorcycle rot on-off 035-5300-015PC 815 PC board, display 035-5300-815Q 710 PNP general purpose 576-0003-650Q 711 NPN general purpose 576-0003-658Q 712 NPN general purpose 576-0003-658 R 800 180k ohm ±5% 1/8W smd 569-0105-184R 801 100k ohm ±5% 1/8W smd 569-0105-104R 802 100k ohm ±5% 1/8W smd 569-0105-104R 803 62 ohm ±5% 2010 .75W smd 569-0135-620R 804 62 ohm ±5% 2010 .75W smd 569-0135-620R 805 62 ohm ±5% 2010 .75W smd 569-0135-620R 806 62 ohm ±5% 2010 .75W smd 569-0135-620R 807 510 ohm ±5% 1/8W smd 569-0105-511R 808 62 ohm ±5% 2010 .75W smd 569-0135-620R 809 62 ohm ±5% 2010 .75W smd 569-0135-620R 810 510 ohm ±5% 1/8W smd 569-0105-511R 811 10k ohm ±5% 1/8W smd 569-0105-103R 812 10k ohm ±5% 1/8W smd 569-0105-103
83 S 001 DIP switch, 10-position 583-5100-210S 154 On-off/Vol push on w/50k pot std 562-0018-075 On-off/Vol rot on-off , motorcycle 562-0018-077S 155 Switch rotary and push 583-2042-001 U 710 LCD driver, PCF8576TD 544-2027-010U 711 LCD driver, PCF8576TD 544-2027-010U 712 Regulator, 8V 0.5A 78M08 544-2003-081 W 103 Cable assy, display - logic bd 023-5300-025 DISPLAY CONTROLLER BOARD C 001 4.7 µF 25V tantalum smd 510-2627-479C 002 .1 µF ±10% X7R 50V cer smd 510-3675-104C 003 10 µF 25V tantalum smd 510-2627-100C 004 .1 µF ±10% X7R 50V cer smd 510-3675-104C 005 .1 µF ±10% X7R 50V cer smd 510-3675-104C 006 .1 µF ±10% X7R 50V cer smd 510-3675-104C 007 .1 µF ±10% X7R 50V cer smd 510-3675-104C 009 .1 µF ±10% X7R 50V cer smd 510-3675-104C 010 .1 µF ±10% X7R 50V cer smd 510-3675-104C 011 .1 µF ±10% X7R 50V cer smd 510-3675-104C 012 4.7 µF 25V tantalum smd 510-2627-479C 013 .1 µF ±10% X7R 50V cer smd 510-3675-104C 016 .1 µF ±10% X7R 50V cer smd 510-3675-104C 017 4.7 µF 25V tantalum smd 510-2627-479C 018 .1 µF ±10% X7R 50V cer smd 510-3675-104C 020 .01µF ±10% X7R cer smd 510-3675-103C 021 .1 µF ±10% X7R 50V cer smd 510-3675-104C 022 .1 µF ±10% X7R 50V cer smd 510-3675-104C 023 .1 µF ±10% X7R 50V cer smd 510-3675-104C 024 .1 µF ±10% X7R 50V cer smd 510-3675-104C 029 1.0 µF 10V tantalum smd 510-2624-109C 030 10 µF 25V tantalum smd 510-2627-100C 031 4.7 µF 25V tantalum smd 510-2627-479C 032 .1 µF ±10% X7R 50V cer smd 510-3675-104C 126 .01 µF ±10% X7R cer smd 510-3675-103C 127 1.0 µF 10V tantalum smd 510-2624-109C 128 1.0 µF 10V tantalum smd 510-2624-109C 129 .1 µF ±10% X7R 50V cer smd 510-3675-104C 130 .047 µF ±10% X7R cer smd 510-3605-473 CR 001 5.6V zener SOT-23 523-2016-569CR 002 5.6V zener SOT-23 523-2016-569CR 003 5.6V zener SOT-23 523-2016-569CR 004 5.6V zener SOT-23 523-2016-569CR 005 5.6V zener SOT-23 523-2016-569CR 006 5.6V zener SOT-23 523-2016-569CR 007 5.6V zener SOT-23 523-2016-569CR 008 5.6V zener SOT-23 523-2016-569CR 009 5.6V zener SOT-23 523-2016-569CR 010 5.6V zener SOT-23 523-2016-569CR 011 5.6V zener SOT-23 523-2016-569CR 012 PIN switching diode 523-1504-001CR 013 5.6V zener SOT-23 523-2016-569CR 014 PIN switching diode 523-1504-001 DS 727 LCD assembly 549-4501-010F 001 Fuse 2.0 A smd 534-5001-009 J 700 Connector, 16-pin 515-7000-668
84 J 701 Connector, micro-miniature 515-7113-073J 702 Connector, 9-pin ZIF flex 515-7111-321J 704 Connector, 5-pin (PA bd cable) 515-7111-254 PC 001 PC board, display controller rev. 5 035-5300-810 5 Q 002 NPN general purpose 576-0003-658Q 004 NPN digital w/resistors 576-0003-616Q 005 NPN digital w/resistors 576-0003-616Q 006 NPN digital w/resistors 576-0003-616 R 002 330k ohm ±5% 1/16W smd 569-0155-334R 003 10k ohm ±5% 1/16W smd 569-0155-103R 005 100k ohm ±5% 1/16W smd 569-0155-104R 006 10k ohm ±5% 1/16W smd 569-0155-103R 007 10k ohm ±5% 1/16W smd 569-0155-103R 008 10k ohm ±5% 1/16W smd 569-0155-103R 009 10k ohm ±5% 1/16W smd 569-0155-103R 010 10k ohm ±5% 1/16W smd 569-0155-103R 011 47k ohm ±5% 1/16W smd 569-0155-473R 012 47k ohm ±5% 1/16W smd 569-0155-473R 013 47k ohm ±5% 1/16W smd 569-0155-473R 014 47k ohm ±5% 1/16W smd 569-0155-473R 015 200k ohm ±5% 1/16W smd 569-0155-204R 016 200k ohm ±5% 1/16W smd 569-0155-204R 017 47k ohm ±5% 1/16W smd 569-0155-473R 018 47k ohm ±5% 1/16W smd 569-0155-473R 019 300 ohm ±5% 1/8W smd 569-0105-301R 020 47k ohm ±5% 1/16W smd 569-0155-473R 021 100k ohm ±5% 1/16W smd 569-0155-104R 022 300 ohm ±5% 1/8W smd 569-0105-301R 023 10k ohm ±5% 1/16W smd 569-0155-103R 024 10k ohm ±5% 1/16W smd 569-0155-103R 025 10k ohm ±5% 1/16W smd 569-0155-103R 026 10k ohm ±5% 1/16W smd 569-0155-103R 027 51 ohm ±5% 1/8W smd 569-0105-510R 028 100k ohm ±5% 1/16W smd 569-0155-104R 029 100k ohm ±5% 1/16W smd 569-0155-104R 030 10k ohm ±5% 1/16W smd 569-0155-103R 031 300ohm ±5% 1/16W smd 569-0155-301R 032 47k ohm ±5% 1/16W smd 569-0155-473R 033 47k ohm ±5% 1/16W smd 569-0155-473R 035 47k ohm ±5% 1/16W smd 569-0155-473R 036 620 ohm ±5% 1/8W smd 569-0105-621R 037 620 ohm ±5% 1/8W smd 569-0105-621R 038 47k ohm ±5% 1/16W smd 569-0155-473R 039 300ohm ±5% 1/16W smd 569-0155-301R 040 10k ohm ±5% 1/16W smd 569-0155-103R 041 3.3k ohm ±5% 1/16W smd 569-0155-332R 042 10k ohm ±5% 1/16W smd 569-0155-103R 043 4.7k ohm ±5% 1/16W smd 569-0155-472R 044 10k ohm ±5% 1/16W smd 569-0155-103R 045 10k ohm ±5% 1/16W smd 569-0155-103R 046 47k ohm ±5% 1/16W smd 569-0155-473R 047 10k ohm ±5% 1/16W smd 569-0155-103R 048 47k ohm ±5% 1/16W smd 569-0155-473R 049 47k ohm ±5% 1/16W smd 569-0155-473R 050 47k ohm ±5% 1/16W smd 569-0155-473R 051 47k ohm ±5% 1/16W smd 569-0155-473R 052 47k ohm ±5% 1/16W smd 569-0155-473R 054 10k ohm ±5% 1/16W smd 569-0155-103R 055 4.7k ohm ±5% 1/16W smd 569-0155-472R 056 10k ohm ±5% 1/16W smd 569-0155-103R 057 4.7k ohm ±5% 1/16W smd 569-0155-472R 058 10k ohm ±5% 1/16W smd 569-0155-103R 059 47k ohm ±5% 1/16W smd 569-0155-473R 060 47k ohm ±5% 1/16W smd 569-0155-473R 061 47k ohm ±5% 1/16W smd 569-0155-473R 062 10k ohm ±5% 1/16W smd 569-0155-103R 063 10k ohm ±5% 1/16W smd 569-0155-103R 064 10k ohm ±5% 1/16W smd 569-0155-103R 065 10k ohm ±5% 1/16W smd 569-0155-103R 066 3.3k ohm ±5% 1/16W smd 569-0155-332R 067 47k ohm ±5% 1/16W smd 569-0155-473
85 R 068 10k ohm ±5% 1/16W smd 569-0155-103R 069 10k ohm ±5% 1/16W smd 569-0155-103R 070 10k ohm ±5% 1/16W smd 569-0155-103R 071 47k ohm ±5% 1/16W smd 569-0155-473R 072 10k ohm ±5% 1/16W smd 569-0155-103R 073 10k ohm ±5% 1/16W smd 569-0155-103R 074 10k ohm ±5% 1/16W smd 569-0155-103R 075 10k ohm ±5% 1/16W smd 569-0155-103R 076 10k ohm ±5% 1/16W smd 569-0155-103R 077 10k ohm ±5% 1/16W smd 569-0155-103R 078 10k ohm ±5% 1/16W smd 569-0155-103R 079 5.1kohm ±5% 1/16W smd 569-0155-512R 080 300ohm ±5% 1/16W smd 569-0155-301R 082 47k ohm ±5% 1/16W smd 569-0155-473R 083 3.3k ohm ±5% 1/16W smd 569-0155-332R 084 10k ohm ±5% 1/16W smd 569-0155-103R 085 100k ohm ±5% 1/16W smd 569-0155-104R 087 10k ohm ±5% 1/16W smd 569-0155-103R 089 1k ohm ±5% 1/16W smd 569-0155-102R 090 10k ohm ±5% 1/16W smd 569-0155-103R 091 10k ohm ±5% 1/16W smd 569-0155-103R 092 10k ohm ±5% 1/16W smd 569-0155-103R 093 10k ohm ±5% 1/16W smd 569-0155-103R 094 10k ohm ±5% 1/16W smd 569-0155-103R 095 10k ohm ±5% 1/16W smd 569-0155-103R 096 10k ohm ±5% 1/16W smd 569-0155-103R 097 10k ohm ±5% 1/16W smd 569-0155-103R 098 10k ohm ±5% 1/16W smd 569-0155-103R 099 10k ohm ±5% 1/16W smd 569-0155-103R 100 10k ohm ±5% 1/16W smd 569-0155-103R 101 10k ohm ±5% 1/16W smd 569-0155-103R 102 10k ohm ±5% 1/16W smd 569-0155-103R 103 1.2M ohm ±5% 1/16W smd 569-0155-125R 104 200k ohm ±5% 1/16W smd 569-0155-204R 105 240k ohm ±5% 1/16W smd 569-0155-244R 107 82k ohm ±5% 1/16W smd 569-0155-823R 108 160k ohm ±5% 1/16W smd 569-0155-164R 109 1k ohm ±5% 1/16W smd 569-0155-102R 110 10k ohm ±5% 1/16W smd 569-0155-103R 111 47k ohm ±5% 1/16W smd 569-0155-473R 112 100k ohm ±5% 1/16W smd 569-0155-104R 113 100k ohm ±5% 1/16W smd 569-0155-104R 114 100k ohm ±5% 1/16W smd 569-0155-104R 115 1k ohm ±5% 1/16W smd 569-0155-102R 116 47k ohm ±5% 1/16W smd 569-0155-473 U 002 Op am, quad MC3303 544-2020-008U 003 RS-485 driver SN65176 544-2023-027U 009 Microcontroller MC68HC908 544-9100-007U 012 5V regulator, 300 mA ADP3367 544-2032-009U 045 3-state noninv amp TC74VHC125 544-3991-125U 047 5V regulator, 300 mA ADP3367 544-2032-009U 054 Schmitt trigger, hex 74HC14 544-3991-014U 055 Flip-flop, dual 74HC74 544-3991-074U 056 Buffer, open drain hex MM74C906 544-3716-906 Y 002 4.9152 MHz crystal 521-3060-024 REMOTE CONTROL UNIT UNIQUE PARTS A 001 Remote audio amp bd assy (rev) 023-5300-751 Remote audio amp bd assy (unrev) 023-5300-750 (see separate listing which follows) A 002 Front panel assembly 023-5300-810 (see preceding listing) A 755 Audio PA board cable 023-5300-755HW 001 Washer, poly 0.937 diameter 596-6400-015HW 002 Washer, SS spring 3/4 OD 596-9260-001HW Screw, captive pan head .75 575-9606-018
86 003 MP 001 Knob, remote control unit 032-0792-015MP 002 Mounting bracket, rem ctrl unit 017-2226-050MP 003 Gasket 032-0792-066MP 005 Housing, remote control unit 032-0792-130MP 006 Rear cover, remote control unit 032-0792-135NP 002 Johnson label 559-9001-310W 003 Control cable, 17-ft 597-2002-262 Control cable, 8-ft motorcycle 597-2002-259 Control cable, 50-ft 597-2002-263W 104 Control unit pigtail cable, std 597-2002-264 Ctrl unit pigtail cable, motorcycle 597-2002-274AUDIO AMP BOARD (REVISED) Part No. 023-5300-751 C 001 15 µF 20V tantalum smd 510-2626-150C 002 15 µF 20V tantalum smd 510-2626-150C 003 0.1 µF X7R ±10% 50V cer smd 510-3606-104C 004 1 µF 35V tantalum smd 510-2628-109C 005 0.1 µF X7R ±10% 50V cer smd 510-3606-104J 001 Header, 2-pin right angle 515-7100-602J 002 Connector, 5-pin 515-7111-254PC 001 PC board, audio amp revised 035-5300-75002Q 001 NPN general purpose smd 576-0003-616R 001 7.5k ohm ±5% 1/8W smd 569-0155-752R 003 10k ohm ±5% 1/8W smd 569-0155-103U 001 Audio amp, 3W TDA7056A 544-2006-025 Std. DC Power Cable AssemblyPart No. 023-9750-010 A 001 Fused DC power cable 023-9650-008 (see separate listing) A 002 Mic clip ground wire 023-7171-911EP 002 Ring terminal, 3/4 10-12 AWG 586-0001-036EP 003 Ring terminal, 3/8 10-12 AWG 586-0001-019F 101 Fuse, 15 amp 32V 534-0003-038HW 000 Key extraction tool 017-2226-000HW 002 Screw, 4-40 x 3/8 pan head (1) 575-0604-012HW 003 Screw, 4-24 x 1/4 phil (3) 575-3604-008HW 004 Screw, 4-20 x 5/8 phil (3) 575-5604-020MP 001 Heavy-duty mic clip 023-3514-001Fused DC Power Cable Part No. 023-9650-008 EP 101 Female crimp pin 515-9032-540FH 001 Fuse holder in-line includes: Contact 534-1004-037 Body 534-1004-031 Knob 534-1004-032 Spring 534-1004-035HW 101 Wire seal 574-9025-035ML 001 Negative ground warning tag 559-4014-001ML 002 Jump start warning label 559-4057-010P 101 2-pin female power connector 515-9032-535W 101 Wire, 12 AWG stranded blue 597-7021-206W 102 Wire, 12 AWG stranded red 597-7021-202 Accessory Wire Harness Kit Part No. 023-9750-011 Fuseholder components: EP 001 Contact 586-9004-001F 001 Fuse, 1A 250V FB AGC 534-0003-020MP001 Fuseholder body 534-1004-031MP002 Fuseholder knob 534-1004-032MP003 Fuseholder spring 534-1004-035HW 001 Pin contact, crimp type 515-1501-055P 101 8-pin receptacle housing 515-1501-050
87 Front Mounting Bracket Assembly Part No. 023-9750-012 HW 001 Self-drilling screw 1/4 (4) 575-9077-565HW 002 Self-drilling screw #10 (4) 575-9077-545MP 101 Knob 10-32 1/2 547-0016-007MP 201 Transceiver mounting bracket 017-2226-034Amplified Dynamic MicrophonePart No. 250-0740-310 C 001 3.3 µF 16V tantalum chip 510-2625-339C 002 220 pF ±5% NPO 50V cer chip 510-3602-221EP001 Contact .038" diameter 586-9008-100EP002 Mic cord w/Hirose connector 597-2002-255EP004 Terminal (on hanger) 022-0069-011HW001 Screw 4-20 x 3/8 575-5604-012HW004 Screw 2-56 x 3/8 575-1602-012MK001 Dynamic mic cartridge 589-1011-003MP001 Case front black 032-0426-100MP002 Case back black 032-0427-100MP003 Actuator black 032-0428-050MP004 Cartridge gasket 032-0429-075MP005 Blast filter 018-1033-002MP006 Switch bracket 017-1885-030MP007 Hanger button 013-1216-005MP008 Crimp retainer 017-2222-006MP009 Rubber bumper 018-0798-009MP010 Backing plate 015-0876-026MP011 Strain relief, mic cord 032-0429-086MP012 Shim support, rubber bumper 017-2222-007MP020 Foam support 018-0798-012NP001 Nameplate 559-0039-026PC001 PC board, amplifier 035-0441-020Q 001 NPN amplifier SOT-23 576-0003-658R 001 51k ohm ±5% 1/8W chip 569-0115-513R 002 18 ohm ±5% 1/8W chip 569-0115-180S 001 Leaf switch SPST 583-1004-03115 Watt, 4.0-Ohm Speaker (Black) Part No. 250-0151-006 HW001 Strain relief (in case back) 574-0003-008HW002 Screw, self drilling 574-9077-543HW003 Screw, 4-20 x 1/2 pan head 575-5604-016HW005 Foam gasket 018-1126-001HW006 Urethane foam, 1/16 thick 042-0361-318HW008 Screw, 6-19 x 1/4 pan hd phillips 575-5606-008HW009 Terminal lug 586-0005-106LS001 Speaker, 5'' 15W 4.0 ohm 589-1016-003MP001 Case front (black) 032-0758-004MP002 Case back (black) 032-0759-004MP003 Mounting bracket (black) 032-0760-004MP004 Tri knob 10-32 547-0016-004NP001 Overlay, speaker front 559-0072-010P 001 Crimp wire contact 515-5010-055W 001 Speaker wire, 22 AWG (6 ft used) 597-2006-00215W 4.0-Ohm Motorcycle Speaker Part No. 250-0151-015 HW001 Strain relief (in case back) 574-0003-008 Rubber switch boot 574-3500-153HW002 Screw, self drilling 574-9077-543HW003 Screw, 4-20 x 1/2 pan head 575-5604-016HW005 Foam gasket 018-1126-001HW006 Urethane foam, 1/16 thick 042-0361-318HW008 Screw, 6-19 x 1/4 pan hd phillips 575-5606-008HW009 Terminal lug 586-0005-106LS001 Speaker, 5'' 15W 4.0 ohm 589-1016-003MP001 Case front (black) 032-0758-004MP002 Case back, motorcycle (black) 032-0759-006MP003 Mounting bracket (black) 032-0760-004
88 MP004 Tri knob 10-32 547-0016-004NP001 Overlay, speaker front 559-0072-010S 001 Switch, SPST toggle 583-0006-061W 001 Speaker wire, motorcycle 023-0151-011
89 Ref No. Description Part No. HANDHELD CONTROL UNIT Part No. 250-5300-101 A 001 Main board assembly 023-5300-705A 002 Keypad board assembly 023-5300-707A 130 Junction box assembly 023-5300-130 (see separate listing) C 001 4.7 µF 25V tantalum smd 510-2627-479C 002 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 003 10 µF 25V tantalum smd 510-2627-100C 005 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 007 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 008 33 pF ±5% NPO 25V cer smd 510-3674-330C 009 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 010 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 011 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 013 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 014 0.01 µF ±10% X7R 25V cer smd 510-3675-103C 015 0.01 µF ±10% X7R 25V cer smd 510-3675-103C 016 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 017 4.7 µF 25V tantalum smd 510-2627-479C 018 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 019 390 pF ±5% NPO 25V cer smd 510-3674-391C 020 0.01 µF ±10% X7R 25V cer smd 510-3675-103C 021 0.1 µF ±10% X7R 25V cer 510-3675-104smd C 022 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 023 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 025 180 pF ±5% NPO 25V cer smd 510-3674-181C 029 1.0 µF 10V tantalum smd 510-2624-109C 030 10 µF 25V tantalum smd 510-2627-100C 031 4.7 µF 20V tantalum smd 510-2626-479C 032 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 126 0.01 µF ±10% X7R 25V cer smd 510-3675-103C 127 1.0 µF 10V tantalum smd 510-2624-109C 128 1.0 µF 10V tantalum smd 510-2624-109C 129 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 130 4.7 µF 25V tantalum smd 510-2627-479C 131 10 µF 25V tantalum smd 510-2627-100C 132 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 133 10 µF 25V tantalum smd 510-2627-100C 134 10 µF 25V tantalum smd 510-2627-100C 135 4.7 µF tantalum smd 510-2622-479C 136 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 137 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 138 1.0 µF 35V tantalum smd 510-2628-109C 139 0.22 F 5.5V electrolytic 510-9510-055C 140 10 µF 25V tantalum smd 510-2627-100C 141 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 142 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 143 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 144 0.047 µF X7R ±10% cer smd 510-3605-473C 145 0.1 µF ±10% X7R 25V cer smd 510-3675-104
90 C 146 0.1 µF ±10% X7R 25V cer smd 510-3675-104 CR 004- 5.6V zener 523-2016-569 CR 11 CR 012 Pin switching diode 523-1504-001CR 013 5.6V zener 523-2016-569CR 020 5.6V zener 523-2016-569CR 021 5.6V zener 523-2016-569CR 023 5.6V zener 523-2016-569CR 024 Dual color LED, red/grn 549-4001-215CR 025- 5.6V zener 523-2016-569 CR 29 CR 030 Dual diodes, com anodes 523-1504-024CR 031 Dual diodes, com anodes 523-1504-024CR 033 Dual diodes, com anodes 523-1504-024CR 034 Dual diodes, com anodes 523-1504-024 DS 001 LCD, glass 549-4501-011DS 002 Fiber optics, backing 549-4501-032DS 024 LED, green 549-4003-011DS27-35 LED, green 549-4003-011EP 001 Spade terminal #6 586-0003-034HW 01a Screw, 6-32 x 5/16 575-1606-010HW 01b Spacer, keypad board 013-1188-055HW 01c Screw, 4-40 x 1/4 575-1604-008HW 02a Screw, 2-56 x 5/8 Torx black 575-8002-020HW 02b Washer, split lock #4 596-1304-008HW 003 Lockwasher, internal #6 596-1106-009J 003 Connector, 12-pin socket .100 515-5300-001MK 001 Microphone cartridge 589-0301-003 MP 01a Mic hanger button 013-1216-007MP 01b Display bezel 017-2226-048 3MP 01c Mic element isolator 032-0757-834MP 02a Back housing 032-0792-056MP 02b Backplate, fiber optic 032-0792-054backlighting MP 03a Keypad, rubber revised 032-0792-059 2MP 03b Elastomeric connector 515-9900-010MP 004 Fiber sheet 12 x 21 058-0021-002MP 005 Fiber sheet 12 x 21 058-0021-002 MP 006 Gasket seal assembly 587-0792-048MP 008 Front housing assembly 587-0792-058MP 009 Water barrier, microphone 574-5300-001MP 010 Lens, front housing 032-0792-052MP 011 Lens gasket, front housing 574-3500-080MP 012 Lens PSA, front housing 574-3500-082 NP 001 Label, EFJ logo front 559-5000-550 P 001 Connector, 11-pin single row 515-9036-021P 003 Connector, 12-pin single row 515-5300-003 PC 001 Main PC board, rev 3 035-5300-700 3PC 001 Keypad board, rev 0 035-5300-707 Q 002 NPN general purpose 576-0003-658Q 004 NPN digital w/resistors 576-0003-616Q 005 NPN digital w/resistors 576-0003-616Q 006 NPN digital w/resistors 576-0003-616Q 007 NPN general purpose 576-0003-658Q 008 NPN general purpose 576-0003-658Q 009 NPN general purpose 576-0003-658Q 010 PNP general purpose 576-0003-650Q 012 Power MOSFET 20 volt 576-0006-243Q 013 Power MOSFET 20 volt 576-0006-243 R 002 330k ohm ±5% 1/16W smd569-0155-334R 003 10k ohm ±5% 1/16W smd 569-0155-103R 005 100k ohm ±5% 1/16W smd569-0155-104R 006 47k ohm ±5% 1/16W smd 569-0155-473
91 R 007 47k ohm ±5% 1/16W smd 569-0155-473R 008 47k ohm ±5% 1/16W smd 569-0155-473R 009 47k ohm ±5% 1/16W smd 569-0155-473R 010 47k ohm ±5% 1/16W smd 569-0155-473R 011 2.2k ohm ±5% 1/16W smd 569-0155-222R 012 2.2k ohm ±5% 1/16W smd 569-0155-222R 013 2.2k ohm ±5% 1/16W smd 569-0155-222R 015 200k ohm ±5% 1/16W smd569-0155-204R 016 200k ohm ±5% 1/16W smd569-0155-204R 017 2.2k ohm ±5% 1/16W smd 569-0155-222R 018 2.2k ohm ±5% 1/16W smd 569-0155-222R 019 300 ohm ±5% 1/8W smd 569-0105-301R 021 100k ohm ±5% 1/16W smd569-0155-104R 022 300 ohm ±5% 1/8W smd 569-0105-301R 028 100k ohm ±5% 1/16W smd569-0155-104R 029 100k ohm ±5% 1/16W smd569-0155-104R 034 2.2k ohm ±5% 1/16W smd 569-0155-222R 040 10k ohm ±5% 1/16W smd 569-0155-103R 042 10k ohm ±5% 1/16W smd 569-0155-103R 043 4.7kohm ±5% 1/16W smd 569-0155-472R 044 10k ohm ±5% 1/16W smd 569-0155-103R 045 10k ohm ±5% 1/16W smd 569-0155-103R 046 47k ohm ±5% 1/16W smd 569-0155-473R 047 10k ohm ±5% 1/16W smd 569-0155-103R 051 47k ohm ±5% 1/16W smd 569-0155-473R 052 47k ohm ±5% 1/16W smd 569-0155-473R 053 33k ohm ±5% 1/16W smd 569-0155-333R 054 10k ohm ±5% 1/16W smd 569-0155-103R 055 4.7k ohm ±5% 1/16W smd 569-0155-472R 056 10k ohm ±5% 1/16W smd 569-0155-103R 057 4.7k ohm ±5% 1/16W smd 569-0155-472R 058 10k ohm ±5% 1/16W smd 569-0155-103R 059 2.2k ohm ±5% 1/16W smd 569-0155-222R 060 2.2k ohm ±5% 1/16W smd 569-0155-222R 061 2.2k ohm ±5% 1/16W smd 569-0155-222R 062 10k ohm ±5% 1/16W smd 569-0155-103R 063 10k ohm ±5% 1/16W smd 569-0155-103R 064 10k ohm ±5% 1/16W smd 569-0155-103R 065 10k ohm ±5% 1/16W smd 569-0155-103R 066 3.3k ohm ±5% 1/16W smd 569-0155-332R 067 2.2k ohm ±5% 1/16W smd 569-0155-222R 068 10k ohm ±5% 1/16W smd 569-0155-103R 069 10k ohm ±5% 1/16W smd 569-0155-103R 070 10k ohm ±5% 1/16W smd 569-0155-103R 071 2.2k ohm ±5% 1/16W smd 569-0155-222R 072 47k ohm ±5% 1/16W smd 569-0155-473R 073 47k ohm ±5% 1/16W smd 569-0155-473R 074 47k ohm ±5% 1/16W smd 569-0155-473R 075 47k ohm ±5% 1/16W smd 569-0155-473R 076 47k ohm ±5% 1/16W smd 569-0155-473R 077 10k ohm ±5% 1/16W smd 569-0155-103R 078 10k ohm ±5% 1/16W smd 569-0155-103R 079 5.1k ohm ±5% 1/16W smd 569-0155-512R 080 300 ohm ±5% 1/16W smd 569-0155-301R 082 47k ohm ±5% 1/16W smd 569-0155-473R 083 3.3k ohm ±5% 1/16W smd 569-0155-332R 084 10k ohm ±5% 1/16W smd 569-0155-103R 087 10k ohm ±5% 1/16W smd 569-0155-103R 090 10k ohm ±5% 1/16W smd 569-0155-103R 093 10k ohm ±5% 1/16W smd 569-0155-103R 095 10k ohm ±5% 1/16W smd 569-0155-103R 096 10k ohm ±5% 1/16W smd 569-0155-103R 097 10k ohm ±5% 1/16W smd 569-0155-103R 098 10k ohm ±5% 1/16W smd 569-0155-103R 099 10k ohm ±5% 1/16W smd 569-0155-103R 100 10k ohm ±5% 1/16W smd 569-0155-103R 101 10k ohm ±5% 1/16W smd 569-0155-103R 102 10k ohm ±5% 1/16W smd 569-0155-103R 103 1.2M ohm ±5% 1/16W smd 569-0155-125R 104 200k ohm ±5% 1/16W smd569-0155-204R 105 240k ohm ±5% 1/16W smd569-0155-244R 106 47k ohm ±5% 1/16W smd 569-0155-473R 107 82k ohm ±5% 1/16W smd 569-0155-823R 108 160k ohm ±5% 1/16W smd569-0155-164R 109 1k ohm ±5% 1/16W smd 569-0155-102
92 R 110 10k ohm ±5% 1/16W smd 569-0155-103R 111 47k ohm ±5% 1/16W smd 569-0155-473R 112 100k ohm ±5% 1/16W smd569-0155-104R 113 100k ohm ±5% 1/16W smd569-0155-104R 114 100k ohm ±5% 1/16W smd569-0155-104R 115 1k ohm ±5% 1/16W smd 569-0155-102R 116 47k ohm ±5% 1/16W smd 569-0155-473R 118 10k ohm ±5% 1/16W smd 569-0155-103R 119 2.2k ohm ±5% 1/16W smd 569-0155-222R 120 2.2k ohm ±5% 1/16W smd 569-0155-222R 121 10k ohm ±5% 1/16W smd 569-0155-103R 122 47k ohm ±5% 1/16W smd 569-0155-473R 123 47k ohm ±5% 1/16W smd 569-0155-473R 124 10k ohm ±5% 1/16W smd 569-0155-103R 125 2.2k ohm ±5% 1/16W smd 569-0155-222R 126 510 ohm ±5% 1/8W smd 569-0115-511R 127 10k ohm ±5% 1/16W smd 569-0155-103R 128 510 ohm ±5% 1/8W smd 569-0115-511R 129 100k ohm ±5% 1/16W smd569-0155-104R 130 150 ohm ±5% 3/4W smd 569-0135-151R 131 150 ohm ±5% 3/4W smd 569-0135-151R 134 100 ohm ±5% 3/4W smd 569-0135-101R 135 100 ohm ±5% 3/4W smd 569-0135-101R 136 100 ohm ±5% 3/4W smd 569-0135-101R 137 100 ohm ±5% 3/4W smd 569-0135-101R 138 4.7k ohm ±5% 1/16W smd 569-0155-472R 139 4.7k ohm ±5% 1/16W smd 569-0155-472R 140 100k ohm ±5% 1/16W smd569-0155-104R 141 100k ohm ±5% 1/16W smd569-0155-104R 142 100k ohm ±5% 1/16W smd569-0155-104R 143 100k ohm ±5% 1/16W smd569-0155-104R 144 100k ohm ±5% 1/16W smd569-0155-104R 145 180k ohm ±5% 1/16W smd569-0155-184R 146 100k ohm ±5% 1/16W smd569-0155-104R 147 100k ohm ±5% 1/16W smd569-0155-104R 150 10k ohm ±5% 1/16W smd 569-0155-103R 151 10k ohm ±5% 1/16W smd 569-0155-103R 152 10k ohm ±5% 1/16W smd 569-0155-103R 153 1k ohm ±5% 1/8W smd 569-0115-102R 154 1k ohm ±5% 1/8W smd 569-0115-102R 155 1k ohm ±5% 1/8W smd 569-0115-102R 156 1k ohm ±5% 1/8W smd 569-0115-102 S 001 10 Pos DIP switch 583-5100-210S 022 Light touch switch 583-4020-015S 027 Light touch switch 583-4020-015S 029 Light touch switch 583-4020-015S 030 KT series switch, right angle 583-9228-003 U 002 Op amp, quad MC3303 544-2020-008U 003 RS-485 bus transceiver ADM483 544-2023-073U 009 Microcontroller MC68HC908 544-9100-007U 012 Regulator, 5V 300mA ADP3367 544-2032-009U 045 Non-inverting buffer, quad TC74VHC125 544-3991-125U 047 Regulator, 5V 300mA ADP3367 544-2032-009U 054 Schmitt trigger, hex 74C14 544-3991-014U 056 Open drain buffer, hex 74C906 544-3716-906U 057 Regulator, 5V 300mA ADP3367 544-2032-009U 058 Regulator, 8V 0.5A 78M08 544-2003-081U 059 Univ LCD driver PCF8576 544-2027-010U 060 Univ LCD driver PCF8576 544-2027-010U 061 Voltage reference, 2.5V LM4120 544-2032-008U 062 D flip-flop TC7W74FU 544-1010-014U 063 D flip-flop TC7W74FU 544-1010-014 W 001 Coil cord assembly 597-2002-272W 503 Control cable, 17 ft. junc - xcvr 597-2002-267Y 002 Crystal, 4.9152 MHz smd 521-3060-024
93 HHC Junction Box Assembly Part No. 023-5300-130 C 001 2.2 uF 20V tantalum smd 510-2626-229C 002 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 003 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 004 2.2 uF 20V tantalum smd 510-2626-229C 005 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 006 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 008 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 009 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 010 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 011 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 012 1µF X7R ±10% 16V cer smd 510-3606-105C 013 1µF X7R ±10% 16V cer smd 510-3606-105C 014 1µF X7R ±10% 16V cer smd 510-3606-105C 015 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 016 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 018 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 019 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 020 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 021 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 022 1µF X7R ±10% 16V cer smd 510-3606-105C 023 2.2 uF 35V tantalum smd 510-2628-338C 024 10 uF 25V tantalum smd 510-2627-100C 025 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 026 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 027 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 028 1µF X7R ±10% 16V cer smd 510-3606-105C 029 0.1 µF ±10% X7R 25V cer smd 510-3675-104C 030 0.1 µF ±10% X7R 25V cer smd 510-3675-104 F 001 Fuse 2.0 A smd 534-5001-009HW 001 Spacer, 4-40 Hex male/fem 013-1160-103HW 002 Screw, 4-40 x .25 575-0604-008HW 003 Screw, 8-18 hex hd sht mtl 575-3908-016HW 004 Polarizing key box cnt 515-7109-010 J 001 Connector, 10-pin 515-7104-005J 002 Connector, 15-pin PC mt female 515-0506-115J 003 Connector, 15-pin 515-0506-119J 005 3.6 mm (1/8) jack enclosed 515-2001-011J 006 3.6 mm (1/8) jack enclosed 515-2001-011J 007 2.5 mm (3/32) audio jack, stereo 515-2002-040 MP 002 Extrusion 014-0777-023MP 003 Front Panel 017-5300-001MP 004 Back Panel, revision 2 017-5300-003 2MP 005 Mounting bracket, junction box 017-5300-005MP 130 Fiber sheet, 12 x 21 058-0021-002NP 001 Label, HHC junction box 559-5000-501PC 001 PC board, junction box rev 2 035-5300-130 2Q 001 NPN general purpose 576-0003-658Q 002 NPN general purpose 576-0003-658 R 001 30k ohm ±5% 1/16W smd 569-0155-303R 002 20k ohm ±5% 1/16W smd 569-0155-203R 003 220k ohm ±5% 1/16W smd569-0155-224
94 R 004 39k ohm ±5% 1/16W smd 569-0155-393R 005 62k ohm ±5% 1/16W smd 569-0155-623R 006 62k ohm ±5% 1/16W smd 569-0155-623R 007 10k ohm ±5% 1/16W smd 569-0155-103R 008 1k ohm ±5% 1/16W smd 569-0155-102R 009 2.7k ohm ±5% 1/16W smd 569-0155-272R 010 8.2k ohm ±5% 1/16W smd 569-0155-822R 012 20k ohm ±5% 1/16W smd 569-0155-203R 013 30k ohm ±5% 1/16W smd 569-0155-303R 014 20k ohm ±5% 1/16W smd 569-0155-203R 015 20k ohm ±5% 1/16W smd 569-0155-203R 016 20k ohm ±5% 1/16W smd 569-0155-203R 017 220k ohm ±5% 1/16W smd569-0155-224R 018 20k ohm ±5% 1/16W smd 569-0155-203R 019 39k ohm ±5% 1/16W smd 569-0155-393R 020 62k ohm ±5% 1/16W smd 569-0155-623R 021 20k ohm ±5% 1/16W smd 569-0155-203R 022 62k ohm ±5% 1/16W smd 569-0155-623R 023 20k ohm ±5% 1/16W smd 569-0155-203R 024 20k ohm ±5% 1/16W smd 569-0155-203R 025 20k ohm ±5% 1/16W smd 569-0155-203R 026 200k ohm ±5% 1/16W smd569-0155-204R 027 20k ohm ±5% 1/16W smd 569-0155-203R 028 20k ohm ±5% 1/16W smd 569-0155-203R 029 20k ohm ±5% 1/16W smd 569-0155-203R 030 20k ohm ±5% 1/16W smd 569-0155-203R 031 20k ohm ±5% 1/16W smd 569-0155-203R 032 300 ohm ±5% 1/16W smd 569-0155-301R 033 300 ohm ±5% 1/16W smd 569-0155-301R 034 20k ohm ±5% 1/16W smd 569-0155-203R 035 20k ohm ±5% 1/16W smd 569-0155-203R 036 20k ohm ±5% 1/16W smd 569-0155-203R 037 100k ohm ±5% 1/16W smd569-0155-104R 038 20k ohm ±5% 1/16W smd 569-0155-203R 039 20k ohm ±5% 1/16W smd 569-0155-203R 040 20k ohm ±5% 1/16W smd 569-0155-203R 041 100k ohm ±5% 1/16W smd569-0155-104R 042 20k ohm ±5% 1/16W smd 569-0155-203R 043 20k ohm ±5% 1/16W smd 569-0155-203R 044 20k ohm ±5% 1/16W smd 569-0155-203R 045 100k ohm ±5% 1/16W smd569-0155-104R 046 20k ohm ±5% 1/16W smd 569-0155-203R 047 100k ohm ±5% 1/16W smd569-0155-104R 049 150 ohm ±5% 1/16W smd 569-0115-151R 050 10k ohm ±5% 1/16W smd 569-0155-103R 051 10k ohm ±5% 1/16W smd 569-0155-103 S 001 Relay, photo MOS 1.3A 100V 544-1020-035S 002 Relay, photo MOS 1.3A 100V 544-1020-035 U 001 Op amp, quad MC3303 544-2020-008U 003 Op amp, quad MC3303 544-2020-008U 004 Audio amp, stereo 150 mW TPA122 544-2006-030U 005 Switch, bilateral MC14066B 544-3016-066U 006 Op amp, quad MC3303 544-2020-008U 007 Comparator, dual LM2903 544-2025-009U 009 Regulator, 5V 0.5A 78M05 544-2003-079 SIREN CONTROLLER KIT Part No. 250-5300-101 A 001 Siren wire kit 023-5300-101 (see separate listing) A 015 Siren system, w/ctrlr, amp, cable 585-5300-015 Siren Wire Kit Part No. 023-5300-101 F 001 Fuse, 15A 32V 534-0332-015 FH001 Fuseholder, in-line 534-1100-003
95 HW001 Ring terminal, 1/4 12-16 AWG 586-0001-150HW002 Solder splice terminator .100-.175 586-0007-085W 001 Wire, zip cord 14 AWG 597-2006-004W 002 Wire, 14 AWG black stranded 597-7021-400W 003 Wire, 14 AWG red stranded597-7021-402 REMOTE PROG. INTERFACE (RPI) Part No. 023-5300-000 C 003 .1 µF ±10% X7R 50V smd 510-3606-104C 004 .1 µF ±10% X7R 50V smd 510-3606-104C 005 .1 µF ±10% X7R 50V smd 510-3606-104C 010 10 µF 25V tantalum smd 510-2627-100C 011 10 µF 25V tantalum smd 510-2627-100C 014 4.7 µF 10V tantalum smd 510-2624-479C 015 4.7 µF 10V tantalum smd 510-2624-479C 016 10 µF 16V tantalum smd 510-2625-100C 017 10 µF 16V tantalum smd 510-2625-100C 018 10 µF 25V tantalum smd 510-2627-100 CR 001 Schottky diode, 1A/100V 523-0519-031CR 002 Schottky diode, 1A/100V 523-0519-031CR 003 Schottky diode, 1A/100V 523-0519-031CR 004 Schottky diode, 1A/100V 523-0519-031CR 006 Switching diode SOT-23 523-1504-002CR 007 Switching diode SOT-23 523-1504-002CR 008 5.6V zener SOT-23 523-2016-569DS 001 Red/grn LED rt angle 549-4006-001 HW 006 Screw, TT 4-40 x .25 pan hd 575-0604-008HW 012 Polarizing key 515-7109-010 J 001 Jack, 3.6 mm enclosed 515-2001-011J 002 Jack, 9-pos PC mt 515-0506-043J 003 Jack, power PC mt 515-2007-010J 004 Header, 10-pin shrouded 515-7104-005J 007 Jack, 2-pin sgl in-line hdr 515-7100-002J 008 Jack, mini enclosed 515-2002-011 MP 001 Extruded metal enclosure 014-0777-021MP 002 Back panel (DB9 end) 017-2206-017MP 003 Front panel (LED end) 017-2206-016MP 007 Spacer, 4-40 hex male/female 013-1160-103 NP 001 ID/nameplate 559-5000-500PC 001 PC board 035-5300-030 Q 001 NPN general purpose SOT-23 576-0003-658Q 005 NPN general purpose SOT-23 576-0003-658 R 009 1k ohm ±5% 1/8w SMD 569-0115-102R 010 200 ohm ±5% 1/8W smd 569-0115-201R 012 10k ohm ±5% 1/8W smd 569-0105-103R 013 10k ohm ±5% 1/8W smd 569-0105-103R 020 10k ohm ±5% 1/8W smd 569-0105-103R 024 10k ohm ±5% 1/8W smd 569-0115-103R 025 3k ohm ±5% 1/8W smd 569-0115-302R 028 3k ohm ±5% 1/8W smd 569-0115-302R 029 3k ohm ±5% 1/8W smd 569-0115-302R 032 10k ohm ±5% 1/8W smd 569-0115-103R 035 300 ohm ±5% 1/8W smd 569-0115-301R 036 3k ohm ±5% 1/8W smd 569-0115-302R 037 Zero ohm ±5% 1/8W smd 569-0115-001R 038 10k ohm ±5% 1/8W smd 569-0105-103R 039 10k ohm ±5% 1/8W smd 569-0115-103R 040 10k ohm ±5% 1/8W smd 569-0115-103R 041 100k ohm ±5% 1/8W smd 569-0115-104 S 009 DIP switch, 8-pos SPST 583-5100-108 U 001 Regulator, 5V 0.5A 78M05 544-2003-079
96 U 004 RS-232 rx/tx, dual MAX232 544-2023-019U 005 RS-485 bus xcvr SN65176 544-2023-027U 006 Schmitt trigger 74HC14 544-3766-014 Ref No. Description Part No. VHF RF BOARD B11 PCA, VHF, RF, TRANSCEIVER, EFJ E3,E4,J3,L5,L9,L12,L16,L26,L49,L82,P1,P2,P3,R7,R18,R19, R21,R22,R28,R29,R30,R40,R82,R85,R106,R107 NOT PLACED NP C1,C10,C13,C21,C26,C36,C37,C45,C229,C232,C242,C318 NOT PLACED NP J2 PCB, FLEX, EFJ 0P795/D PCB, VHF, RF TRANSCEIVER, EFJ 0P811/B CP1,CP2,CP3,CP4 CAP, 4 UP, 47 PF, ±10%, 50V, NPO, 1206 1C424-470 C2,C6,C42,C43,C44,C47,C96,C97,C99,C109,C120,C121,C141, C164,C182,C192,C195,C285,C288,C291,C304 CAP, CER, 0.1 UF, ±10%,10V, X7R, 0603 1C455-104 C3,C19,C55,C126,C135,C136,C142,C143,C181,C193,C194, C287,C292,C305 CAP, CER, 100 PF, ±5%, NPO, 0603 1C113-101 C4,C20,C29,C69,C101,C102,C106,C110,C111,C114,C127,C128,C129,C130,C131,C134,C137,C140,C145,C150,C151,C152,C153,C163,C169,C176,C189,C199,C200 CAP, CER, 0.01 UF, ±10%, X7R, 0603 1C148-103 C5 CAP, PPS FILM, .0047 UF, ±5%, 16V, LOW ESR, 0805 1C478-472 C7,C9 CAP, CER, 180 PF, NPO, 0603 1C113-181 C8,C274,C303 CAP, CER, 10 PF, ±5%, NPO, 0603 1C113-100 C11,C14,C17,C23,C24,C25,C33,C34,C46,C48,C49,C50,C61,C62,C63,C65,C67,C70,C95,C107,C113,C118,C122,C148,C149,C155,C156,C157,C159,C162,C165,C166,C167,C205,C206,C222,C223,C224,C225,C226,C240,C276,C295,C296,C297,C299,C300,C301,C307 CAP, CER 1000 PF, ±5%, NPO, 0603 1C113-102 C12 CAP, PPS FILM, 0.018 UF. ±5%, 16V, 3216 1C733-B183C15,C298 CAP, CER, 47 PF, ±5%, NPO, 0603 1C113-470 C16 CAP, PPS FILM, .015 UF, ±5%, 16V, 3216 1C478-153 C18,C230,C234,C235,C277 CAP, CER, 39 PF, ±2%, NPO, 0603 1C731-390 C22 CAP, PPS FILM, 0.68 UF, ±10%, 16V, LOW ESR, 3216 1C478-684 C27,C272,C273,C312,C313 CAP, CER, 3.3 PF, ±0.25 PF, 0603 1C450-3R3 C28 CAP, FILM, 0.15 UF, ±20%, 16V, 3216 1C353-J154
97 C30,C293 CAP, PPS FILM, 0.22 UF, ±10%, 25V, LOW ESR, 3216 1C478-224 C31,C139 CAP, CER, 200 PF, ±5%, NPO, 0603 1C113-201 C32 CAP, TANT, 4.7 UF, ±20%, 16V, B CASE 1C166-475 C35,C125,C132,C133,C168,C171,C174,C175,C202,C203,C286,C289,C290,C302 CAP, TANT, 4.7 UF, ±20%, 16V, A CASE 1C573-A475C38,C115 CAP, CER, 33 PF, ±5%, NPO, 0603 1C113-330 C39 CAP, CER, 8.2 PF, ±0.25 PF, 0603 1C450-8R2 C40 CAP, CER, 1.0 PF, ±0.1 PF, NPO, 0603 1C731-1R0 C41,C90,C294 CAP, CER, 470 PF, ±5%, NPO, 0603 1C113-471 C51,C72 CAP, CER, 22 PF, ±5%, LOW E, NPO, 0603 1C731-220 C56 CAP, CHIP, 1.0 UF, ±20%, 10V, X7R, 0603 PKG 73550 C60 CAP, CER, 18 PF, ±5%, NPO, 0603 1C113-180 C64 CAP, CER, 15 PF, ±2%, LOW ESR, HIGH-Q, 0603 1C731-150 C68,C241 CAP, CER, 12 PF, ±5%, NPO, 0603 PKG1C113-120 C89 CAP, CER, 5.6 PF, ±0.25 PF, 0603 1C450-5R6 C98,C123,C154,C284 CAP, TANT, 10 UF, ±20%, 10V, A CASE 1C117-106 C100,C108,C112,C116,C117 CAP, CER, 56 PF, ±5%, NPO, 0603 1C113-560 C103 CAP, CER, 0.012 UF, ±5%, 50V, X7R, 0805 1C399-123 C104,C160,C311 CAP, CER, 4700 PF, ±10%, X7R, 0603 1C148-472 C105,C146,C147,C161,C172,C177,C196,C310 CAP, TANT, 1.0 UF, ±20%, 16V, A CASE 1C118-105 C119,C236,C237 CAP, CER, 82 PF, ±2%, LOW ESR, HI-Q, 0603 1C731-820 C138 CAP, CER, 0.022 UF, ±10%, 50V, X7R, 0805 1C143-223 C144 CAP, CER, 2200 PF, ±10%, X7R, 0603 1C148-222 C158 CAP, CER, 120 PF, ±5%, NPO, 0603 1C113-121 C210 CAP, CER, 82000 PF, ±10%, X7R, 0603 1C148-823 C231,C233,C238,C239 CAP, CER, 6.2 PF, ±0.1 PF, LOW ESR, HI-Q, 0603 1C731-6R2 C270 CAP, CER, 2.7 PF, ±0.25 PF, NPO, 0603 1C113-2R7 C271 CAP, CER, 6.8 PF, ±0.1 PF, LOW ESR, HI-Q, 0603 1C731-6R8
98 C306 CAP, FILM CHIP, 1200 PF, ±5%, 16V, 0805 73697 C308 CAP, FILM CHIP, 4700 PF, ±5%, 16V, 0805 73699 C309 CAP, FILM CHIP, 3300 PF, ±5%, 16V, 0805 73698 D4,D10 TRANS, MOSFET, P-CH, SOT23 1T158-SI2323 D9 DIODE, SILICON, TUNING, SOT23, MV2105 72672 D12,D13 DIODE, PIN, HIGH AVG POWER SMQ, MELF 72663 EC1 SHIELD,COVER, IF LARGE 3M797-2 EC2 SHIELD, COVER, IF SMALL 3M809-2 EC5 SHIELD, COVER, PLL 3M813-2 EC7 SHIELD, POWER AMPLIFIER 3M800 EC9 CLIP, GROUND, 3638001000 72673 EC10 CLIP, SPRINGS, 97-251-02 72674 E1 SHIELD, FENCE, IF LARGE 3M797-1 E2 SHIELD, FENCE, IF SMALL 3M809-1 E5 SHIELD, FENCE, PLL 3M813-1 FB1,FB2,FB3 INDUCTOR, FERRITE LEAD, SMT, 0121 1L137-1210S0 FB4,FB5,FB6,FB7,FB8,FB9,FB10 INDUCTOR, FERRITE BEAD, SMT, 0805 1L137-3 F1 FUSE, FAST-ACTING, 2A, SMT, 0603 1X619-2R0 J1 CONN, COAX PLUG, SMT 1J607-2 L1,L2,L7 INDUCTOR, 270 NH, ±2%, SMT, 1008 1L498-271 L3 INDUCTOR, 68 NH, ±10%, SMT, 1008 1L190-680 L4 INDUCTOR, 390 NH, ±5%, SMT, 0603 1L177-391 L6,L8 INDTR, 12 NH, ±2%, SMT, 0603 1L177-120GL10,L33 INDTR, 120 NH, ±2%, SMT, 0603 1L177-121GL11,L21,L22 INDTR, CHIP, 51 NH, ±2%, HIGH-Q, 0805 78261 L19,L32,L36 INDTR, 180 NH, ±2%, SMT, 0603 1L177-181GL27 INDTR, CHIP, 180 NH, ±2%, 1008 PKG 78126 L28 INDUCTOR, 150 UH, ±10%, 1210 1L514-154 L29,L30 INDUCTOR, WIREWOUND, 10 UH, 1206 1L575-102 L31 INDUCTOR, 220 NH, ±10%, SMT, 1008 1L190-221
99 L35 INDUCTOR, 39 NH, ±5%, SMT, 0603 1L177-390 L40 INDUCTOR, 100 NH, ±5%, SMT, 0603 1L177-101 L44 INDUCTOR, 82 NH, ±5%, SMT, 0603 1L177-820 L46,L47,L48 INDTR, CHIP, 470 NH, 5%, 0603LS 1L835-471 L50,L51,L53,L54 INDTR, 150 NH, ±2%, SMT, 1008 (REFERENCE 78127) 1L498-151 L77,L78 INDTR, 72 NH, ±2%, SMT, 0603 1L177-720GL81 INDUCTOR, 330 NH, ±5%, SMT, 0603 1L177-331 MX1 MIXER, 100-500 MHZ, 7 DB CL, 5 DBM LO 72668 P4,P5,P6,P7,P8 SPRING CONTACT,ELECTRICAL 3C799 Q1,Q2 TRANSISTOR, SMT, NPN, SS RF, SOT-2 1T153-941 Q3,Q4,Q5,Q6,Q7 TRANSISTOR, MOSFET, RDSO, SOT-23 1T159-7002CT RP1 RES, ARRAY, 1K X 4, SMT 1R230-102 R1 RES, 18K, ±5%, SMT, 0603 1R105-183 R2,R6 RES, 560 OHM, ±5%, SMT, 0603 1R105-561 R3 RES, 12K OHM, ±5%, SMT, 0603 1R105-123 R4,R62,R64 RES, 120 OHM, ±5%, SMT, 0603 1R105-121 R5,R8,R109 RES, 620 OHM, ±5%, SMT, 0603 1R105-621 R9 RES, CHIP, 390K OHM, ±5%, 0603 PKG 75886 R10,R113 RES, 240 OHM, ±5%, SMT, 0603 1R105-241 R11,R15,R43,R52,R59,R98 RES, 1.0K OHM, ±5%, SMT, 0603 1R105-102 R12,R14,R32,R42,R58,R69,R76,R102,R103 RES, 10K OHM, ±5%, SMT, 0603 1R105-103 R13 RES, 30 OHM, ±5%, SMT, 0603 1R105-300 R16 RES, CHIP, 12 OHM, ±5%, 0603 PKG 75476 R17 RES, 200 OHM, ±5%, SMT, 0603 1R105-201 R20,R45,R57,R60,R79,R83,R84,R86,R87,R88,R108,R124,R125,R126,R130 RES, 0 OHM, ±5%, SMT, 0603 1R105-0R0 R23,R48,R70,R116 RES, 51 OHM, ±5%, SMT, 0603 1R105-510 R24,R33,R34,R35,R73,R74,R77,R78,R81,R111,R112,R114,R115 RES, 330 OHM, ±5%, SMT, 0603 1R105-331 R25,R27 RES, 470 OHM, ±5%, SMT, 0603 1R105-471 R26 RES, 10 OHM, ±5%, SMT, 0603 1R105-100 R31 RES, 160 OHM, ±5%, SMT, 0603 1R105-161 R36,R117 RES, 2.7K, ±5%, SMT, 0603 1R105-272 R37 RES, 22K OHM, ±5%, SMT, 0603 1R105-223
100 R38 RES, 6.2K, ±5%, SMT, 0603 1R105-622 R39 RES, 36K, ±5%, SMT, 0603 1R105-363 R41 RES, 15K, ±5%, SMT, 0603 1R105-153 R44 RES, 3K OHM, ±5%, SMT, 0603 1R105-302 R46,R54 RES, 220 OHM, ±5%, SMT, 0603 1R105-221 R47,R49,R71,R119 RES, 100 OHM, ±5%, SMT, 0603 1R105-101 R50 RES, 24 OHM, ±5%, SMT, 0603 1R105-240 R51 RES, 3.9K OHM, ±5%, SMT, 0603 1R105-392 R53 RES, 4K OHM, ±5%, SMT, 0603 1R105-473 R55,R61 RES, 100K OHM, ±5%, SMT, 0603 1R105-104 R56 RES, 1.0M OHM, ±5%, SMT, 0603 1R105-105 R63,R65,R66,R67 RES, 75 OHM, ±5%, SMT, 0603 1R105-750 R68 RES, 9.1 OHM, ±5%, SMT, 1206 1R103-9R1 R72 RES, 62 OHM, ±5%, SMT, 0603 1R105-620 R80 RES, 18 OHM, ±5%, SMT, 0603 1R105-180 R99,R100,R101 RES, 390 OHM, ±5%, SMT, 0603 1R105-391 R104,R105 RES, 4.7K OHM, ±5%, SMT, 0603 1R105-472 R110 RES, 270K OHM, ±5%, SMT, 0603 1R105-274 R118 RES, CHIP, 82 OHM, 5%, 0603 75449 R121,R122 RES, CHIP, 1.6K OHM, ±1%, 0603 75885 R123 RES, 2.0K OHM, ±5%, SMT, 0603 1R105-202 U1 VCO, 200-239 MHZ, UMZ-1154-D16 4V510-11 U2,U25 CRYSTAL, 64.455 MHZ, SMT 1Y496-4 U3 MODULE RF AMP, 135-175MHZ, 6.5W 1Q129-RA07M U6 IC, RF AMP, 150-2500 MHZ, GAAS HBT 1Q129-RF2361 U7 SWITCH, PHEMT, SPDT, DC-2.5 GHZ, AS169-73 71728 U9 IC, TEMP SENSOR, -40 TO +125, SOT 1Q126-LM50B1Z U10,U27,U34 IC, REG, LOW DROP OUT, 5.0V, SMT, SO 1Q127-7081-50 U11 IC, IF DIGITIZING SUB-SYSTEM, SM 1Q130-9864U12,U13 IC, REG, LOW DROP OUT, 3.3V, SMT, SO 1Q127-7081-33 U14,U15 IC, CMOS, SCHMMIT INVERTER, SINGLE 1Q128-74V1G14S

Navigation menu